Professional Documents
Culture Documents
by diyhuntress
Create your desk frame by attaching your 1 x 6 side pieces to the top and bottom desk pieces. I used dowel joinery, but
feel free to use whatever joinery works for you!
Once the frame has been made, add your divider and shelf pieces using pocket holes and/or nails and glue.
Build the frame for the pegboard using 1 x 2 boards. Make sure to build it back far enough to t your hinges. At this point
it's also safe to sand & paint your frame!
Add supports to the back of cabinet using back shelf panel and support panel with pocket holes. This is how you will
attach the desk to the wall by drilling screws through these pieces into studs later. Make sure to pre-paint them before
attaching (I used chalkboard paint)!
Cut and attach front panel and add edge banding to the plywood edges.
At this point you can customize this panel with any artwork you’d like! I created mine using painter’s tape and di erent
shades of latex paint (you can check out this process in my YouTube video)!
Attach front panel to desk with hinges & add pistons. You can also add the decorative 3/4″ square dowels to the bottom
shelf. Make sure they are far back enough for hinges and pistons to t.
Hang the desk on the wall before attaching the pegboard. It’s super important you install the desk into as many studs as
possible.
That's it! I chose to hang my desk at arm chair level to pair it with a cute, modern accent chair that I could pull over from
the other side of the room!