Professional Documents
Culture Documents
Flow Control by Pass Kit 1093771
Flow Control by Pass Kit 1093771
This kit contains a flow control bypass valve assembly for use on an WARNING: Risk of personal injury or equipment damage! Refer to Required Tools:
AltaBluet TT adhesive melter. Before the bypass valve assembly can be the safety information provided in the melter manual before
installed, the runup pressure control valve (P/N 1024689, which is servicing the melter. Failure to comply with the safety information 8-mm wrench
contained in kit P/N 1034042) must be installed. provided can result in personal injury, including death.
1. Switch the melter off. 3. Using the M5 washers and nuts 4. Connect tubing from the flow control
provided, mount the flow control bypass bypass valve assembly to the runup
valve assembly to the rear left leg of the pressure control valve.
2. Disconnect power to the melter melter.
at the local power disconnect switch.
NOTE: The runup pressure control
valve (P/N 1024689) should already be
installed on the melter.
1/8 NPT
1/4-in. tube