Professional Documents
Culture Documents
• For bolts at critical locations, apply engine oil to the threads for a uniform tightening force without
catching on the thread peaks.
• For bolts and nuts at critical locations and at locations that cannot be inspected from the outside,
use wire, cotter pins, folded washers, or the like to securely prevent turning.
• If Loctite was used on a removed bolt (there is something white sticking to the thread section when
it is removed), clean the old Loctite off with cleaning fluid, dry the bolt, then apply 2 - 3 drops of Loc-
tite to the thread section of the bolt before tightening.
Bolt and nut retightening [after 1st 50 hr. for new machine] [every 250 hr.]
Tighten and retighten bolts and nuts in each section according to the table. Also before and after
day-to-day work, inspect for loose or fallen out bolts and nuts. Retighten any that are loose and
replace any that have come out.
Inspect and retighten after the first 50 hr. for a new machine and every 250 hr. after that.
61 NST-09-08-005EN
1
Bolt Size and Torque Table
Retightening Torque Table
Bolt nominal Tightening torque
Code Retightening location Wrench
diameter [N•m]
1 Travel motor M16 24 mm 267 - 312
14 M10 17 mm 64 - 73
Hydraulic pump
15 M16 14 mm bar wrench 223 - 247
19 M12 19 mm 88 - 107
Center joint
20 M12 19 mm 109 - 127
21 Cab M16 24 mm 157
22 Battery M10 17 mm 20 - 29
Caution
For items marked with ○ , always apply Loctite #262 or the equivalent and tighten with the specified
torque.
N•m / 9.8 gives the tightening torque in kgf•m.
The tightening for bolts and nuts not otherwise specified in the table above is as follows.
Bolt nominal diameter (size) M6 M8 M10 M12 M14 M16 M18 M20
Wrench [mm] 10 13 17 19 22 24 27 30
Hexagon bolt
Tightening torque [N•m] 6.9 19.6 39.2 58.8 98.1 157.0 196.0 294.0
NST-09-08-005EN 62
2
Bolt Size and Torque Table
63 NST-09-08-005EN
3
Bolt Size and Torque Table
NST-09-08-005EN 64
4
Bolt Size and Torque Table
65 NST-09-08-005EN
5