You are on page 1of 1

EG1–327

5S–FE ENGINE – MATRIX CHART OF PROBLEM SYMPTOMS

MATRIX CHART OF PROBLEM SYMPTOMS


When the malfunction code is not confirmed in the diagnostic trouble code check and the problem still can
not be confirmed in the basic inspection, then proceed to this step and perform troubleshooting according
to the numbered order given in the table below.

lG–10,30*
Manifold absolute pressure sensor circuit EG1–372

EG1–396

EG1 –424
EG1–410
EG1–400
EG1–383

EG1–428

ST–19,21
EG1–390

EG1–415
EG1–403
EG1–408

EG1–419

IG–11,30
IG–6,26*
IG–8,28*

EG1–23
AX1–68
IN–36
See page

VSV circuit for fuel pressure control


Park/Neutral position switch circuit

Ignition signal circuit (Spark test)


Suspect area

Back up power source circuit


Switch condition signal circuit

ECM power source circuit

Starter and Starter relay

Engine control module


A/C cut control circuit
Starter signal circuit

Fuel system circuit


IAC valve circuit
Injector circuit
EG R system

Compression
Ignition coil
Spark plug

Distributor
Symptom

A/T faulty
Engine does not crank
Does not

No initial combustion
start

No complete combustion

Under normal condition


Difficult to

Cold engine
start

Hot engine

Incorrect first idle

High engine idle speed


Poor Idling

Low engine idle speed


Rough idling

Hunting

Hesitation/Poor acceleration
Driveability

Muffler explosion (after fire)


Poor

Surging

Soon after starting

After acceleration pedal depressed


Engine Stall

After acceleration pedal released

During A/C operation

When N to D shift

*: Except California specification vehicles.

You might also like