Professional Documents
Culture Documents
ACTICIDE DT
Product Information
®
ACTICIDE DT is a broad-spectrum biocide for the protection of aqueous and solvent based coatings and
similar products from fungal and algal growth and for the preparation of timber preservation formulations.
Biocidal Properties
®
ACTICIDE DT possesses a wide spectrum of biocidal activity including efficacy against the following
relevant spoilage organisms:
Test Organisms
Moulds/Yeasts
Alternaria alternata Coniophora puteana Penicillium glaucum
Aspergillus niger Coriolus versicolor Poria placenta
Aureobasidium pullulans Epidermophyton floccosum Saccharomyces cerevisiae
Candida albicans Gloeophyllum trabeum Trametes versicolor
Chaetomium globosum Microsporum canis Trichoderma viride
Cladosporium cladosporoides Penicillium funiculosum Ulocladium sp.
Bacteria Algae
Bacillus subtilis Cyanobacteria: Green Algae
Escherichia coli Ababaena flos-aquae Chlorella pyrenoidosa
Pseudomonas aeruginosa Nostoc commune Scenedesmus sp.
Pseudomonas fluorescens Microcystis sp.
Staphylococcus aureus
For protection of water-based products from bacterial and fungal infection in the wet state the additional use
of one of Thor's wide range of in-can preservatives is recommended.
Optimum use concentrations will depend on the required properties of the product to be protected and the
environment in which it is to be exposed. Normal addition levels are in the range 0.2 - 0.6% for coatings.
The local Thor Microbiological Technical Centre can assist in determining the precise concentration
required for specific applications, especially for wood preservation use.
Method of Use / Compatibility
®
ACTICIDE DT can be added at any stage in the production process but to ensure optimum even dispersion
it is recommended that it be stirred efficiently into the formulation as early as possible during the
manufacturing cycle. Care should be taken to ensure that temperature, pH and redox potential at the point of
addition are suitable for stability of the product. In addition, other substances such as ammonia, primary and
secondary amines and strong oxidising or reducing agents such as hypochlorites, bisulphites, meta-
bisulphites and hydrogen sulphide, can also affect the product's stability.
®
ACTICIDE DT is compatible with most raw materials used in the products in which its use is recommended.
However, users are advised to conduct their own stability tests before initial use or seek specific assistance
from Thor.
The information contained in this leaflet is intended to be of assistance to users but is without guarantee.
Variations can occur in application and users are advised to conduct their own tests. Suggestions for use
neither give nor imply any freedom from patent infringement.
Use biocides safely. Always read the label and product information before use.
PDS_ACTICIDE_DT&A_2833&GB_V01_30Aug13/DSC-SCK