Professional Documents
Culture Documents
Installation Instructions
Panel Mounting
ENCLOSURE
FIELD
NOTE: At least 2.88 SUPPLIED (REF.)
inches (73.0 mm) FOR PLACEMENT
between drill holes OF SECOND DRILL
(top and bottom) to 2
HOLE #29 (≈0.125" dia)
accomodate side by (≈3.2 mm)
side arrangement of
2 or more modules. (REF.)
FOR PLACEMENT
1 OF FIRST DRILL
2" ) HOLE #29 (≈0.125" dia)
2.1mm
3.8 (≈3.2 mm)
(5
8" )
2.8mm
3.0
(7
8" )
6.3 mm
.9
61
(1
2
8" )
2.8mm
.0
(73
3" m)
.2
m 1
(76
#8-32 X 3/4"
NOTE: Minimum distance SELF TAPPING
from base of enclosure SCREW
to place first drill hole. (2 PLACES)
997-030030-1
03/03 Page 1 of 4
6400 and 6400-I/O Power Connector Location
Warning: If using a 24 Vac power supply to power the Comfort Controller, do not use it to also
power other non-Comfort Controller modules or field devices (for example, actuators).
Pin Power
Number Connector
POWER
CONNECTOR
(PLUG-IN TYPE
ON 6400
MODULE)
CAUTION: Connect Pin 1
on each Comfort 2
1
Controller module's 3
power connector to
chassis (earth) ground.
(–)
WARNING: Failure to correctly wire power 24 (+)
connector can permanently VAC
damage 6400 module. OR CHASSIS
33VDC GND
997-030030-1
Page 2 of 4 03/03
6400 and 6400-I/O Communication Connector Location
PLUG-IN
TYPE
CONNECTOR
ON 6400
MODULE
WHT, CLEAR
OR GRN
1
2
3
(+) RED
G
(–)
NOTE: Do not bundle power and BLK
communication wiring with
sensor and device wiring. SHIELD
CCN
COMMUNICATION
997-030030-1
03/03 Page 3 of 4
Communication Connections
The figure below shows I/O communication connections between Comfort Controller 6400 and
6400-I/O modules.
COMMUNICATION DAISY
ENCLOSURE 6400 12 31
2 3 CHAIN BETWEEN
MODULES
3
3
(FIELD MODULE
SUPPLIED) SHIELD
BY-PASSES
6400/IO MODULES
MODULE
1
2 SHIELDS
2 2
13 ATTACHED
3 3
12 13 TO CHASSIS
GROUND
(ON ONE
END ONLY)
TO NEXT
1 31
ELEMENT
1 13 2 ON
23
12 13 2 CCN BUS
3
BOTTOM VIEW
OF MODULES
Related Documentation
For more information on the Comfort Controller 6400, see the following:
997-030030-1
Page 4 of 4 03/03