Professional Documents
Culture Documents
2019
1) Which section of CIVIL AVIATION ACTS 2006 empowered the Promulgation of the
NIGERIA CIVIL AVIATION REGULATIONS:
a) Section 27
b) Section 30
c) Section 17
2) The Power to make Regulations for Civil Aviation Activities in Nigerian is vested on:
4) The ratings that an Aircraft maintenance Engineer can obtain in current Regulations
are:
a) A, B1 and B2
b) Category A, Category C, Category X & Category R
c) Airframe, Powerplant and Avionics
a) 23 years old
b) 21 years old
c) 18 years old
9) The total experience for Airframe, Powerplant and Avionics ratings for an applicant
undergoing training in an Approved Training Organisation is:
a) 12 Months
b) 48 Months
c) 54 Months
10) Which of these statement is correct for Applicant for Airframe, Powerplant and
Avionics
ratings:
11) Which of the following statements is correct for an applicant for Aircraft Maintenance
Engineer’s license and ratings?
a) He/she had satisfactorily performed the work at an earlier date or received course
of training on the aircraft, engine, propeller or appliances.
b) He/she had received training acceptable to the Authority on the tasks to be
performed or had seen other Aircraft maintenance performing such tasks.
c) He/she had performed the task satisfactorily before or performed the task
under the direct supervision of a repair specialist who is appropriately rated
who had done such tasks earlier.
b) Two years
c) Five years
14) A licensed AME may not exercise the privileges of his or her license or ratings unless
within the preceding 24 months.
a) Has served as an AME under his/her license and rating for at least six
months
b) Has observed the performance of an annual or 100 hour inspection in the area of
his license or ratings
c) Been engaged in combination of (A) or (B)
15) Which of the following statement is correct for Inspection Authorization applicant?
a) The applicant must be at least 23years old and have an AME license with
either Airframe or Powerplant rating.
b) The applicant must have an AME license for at least 3 years with Airframe and
Powerplant ratings.
c) The applicant must have an AME license for at least 3yrs with Avionics rating and
have at least 2 years maintenance of aircraft experience.
a) No knowledge test is required for type rating licence provided the applicant
had successfully undergone the type training on the aircraft for the type
rating .
b) Must pass knowledge test.
c) Once the applicant had served as designated examiner, he or she automatically
qualifies to exercise the privileges of type rating.
17) An application for initial issue of AOC shall be made at least ------------- before the
date of
intended operation.
a) 30 days
b) 90 days
c) 180 days
a) 12 Months
b) 18 Months
c) 24 Months
20) Each report of failures, malfunctions and defects referred to in Regulation 5.5.1.4
shall be
made after the occurrence of failures within:
a) 3 days
b) 7 days
c) 10 days
a) Inspect and approve for return to service any aircraft over 5700kg maximum take-
off weight.
b) Inspect and approve for return to service any aircraft maintained in accordance
with continuous maintenance programme approved under part 9 of Nigeria CAR.
c) Not perform any maintenance stated in (A) & (B)
23) For applicant to be issued with Aircraft Repair Specialist license and ratings he or she
must
be:
a) 18 years old
b) 21 years old
c) 23 years old
24) Which of the following statement is nottrue for an applicant for validation of a
foreign AME Licence?
a) Must hold a valid foreign AME Licence .
b) Must be recommended by his employer to the satisfaction of the Authority to
be able to perform the job.
c) Must pass a knowledge test in the Nigerian Air Law applicable to AME
Licensing.
27) The Minimum Equipment list items are grouped according to:
a) Transfer to the lessee upon the lease of an aircraft within or outside Nigeria
b) Transfer to the FAA after selling the aircraft in Nigeria.
c) Transfer to the buyer upon sale of the aircraft within Nigeria
30) The authority will consider an Air Operator Certificate valid only when accompanied
by:
a) Maintenance Manual issued by the manufacturer which identifies the specific type
of Commercial Air Transport operation to be undertaken.
b) Minimum Equipment List approved by the Authority which identifies the special
type of Commercial Air Transport authorized.
c) Operations Specification issued by the Authority which identifies the specific
type of the operation.
31) Which of the following situations does not qualify for the issue of Special Flight
Permit?
a) A pilot licensed by the Authority if the aircraft is not used for Commercial
Operation.
b) The AOC holder when specified in the operation Specifications
c) All of the above.
34) Compliance with Airworthiness Directive or Manufacturer’s Service Bulletins are
normally
recorded in:
35) What is the means by which Aviation Authority notifies aircraft owners and other
interested
persons of unsafe conditions and prescribes the condition under which the product
may continue to be operated?
a) Airworthiness Directives
b) Airworthiness Alerts
c) Aviation Safety Bulletin
a) 2 years from the date the aircraft or aeronautical product to which the work
relates was release from the AMO.
b) 3 years from the date of the issue of the Certificate of Release to Service
c) 6 months after issue of Certificate of Release to Service (CRS)
a) NCAA
b) The Manufacturer
c) The Operator
43) By what means does the NCAA regulate the Civil Aviation Industry in Nigeria?
44) The responsibility of ensuring that the aircraft is in airworthy and safe conditions is
that of:
47) From which of the following person will the Authority accept application
for type certification design approval?
a. A person holding Nigerian AME license and working in an approved
maintenance organization.
b. A person holding a Nigerian Patent License.
c. A person holding an appropriate Design Organization approval.
50) An application for initial issue of AOC shall be made at least _____before ---
a) 30 days
b) 180 days before the date of intended start
c) 90 days