Professional Documents
Culture Documents
1. If an aircraft is yawing to the left, where would you position the trim
tab on the rudder?.
Option A. To the centre.
Option B. To the right.
Option C. To the left.
2. When a leading edge flap is fully extended, what is the slot in the
wing for?
Option A. To allow the flap to retract into it when it retracts.
Option B. To re-energise the boundary layer.
Option C. To increase the lift.
9. Semi-monocoque construction.
Option A. u9lizes the safe-life design concept.
Option B. is used only for the fuselage.
Option C. offers good damage resistance.
18. Pitot' and 'Static' lines during a cabin pressure test should be.
Option A. cross connected.
Option B. disconnected.
Option C. connected.
19. If the cabin pressure fails to reach its maximum cabin pressure
differential the.
Option A. discharge valve should be adjusted.
Option B. pressure controller should be adjusted.
Option C. outward relief valve is inoperative.
21. If an aircraft flying in still air at 400 knots, encounters a head wind
of 50 knots, its ground speed is.
Option A. 450 knots.
Option B. 350 knots.
Option C. 400 knots.
33. When a FADEC system loses air data input it goes to.
Option A. soft reversion.
Option B. hard reversion.
Option C. mechanical reversion.
42. Using a hand pump, a force of 100 psi has been built up in a
hydraulic system. The handpump piston is 1inch in diameter. A 1/2inch
line connects to the pump to an actuatingcylinder 2inch in diameter.
What is the pressure in the line between the hand pump and the
actuating cylinder?
a. 150 PSI
b. 100 PSI
c. 200 PSI
46. When bleeding aircraft brakes, one of the indications that the air
has been purged out is;
a. Full brake pedal travel
ii. Normal braking
iii. Fail safe protection
iv. Locked wheel skid control
v. Touchdown protection
vi. Takeoff protection
a. 1, 2, 5 and 6
b. 1, 3, 4 and S
c. 1, 2, 3 and 4
47. Which of the following is most likely to cause landing gear warning
system to sound?
a. Landing gear locked down and throttle retarded
b. Landing gear not locked down and throttle retarded
c. Landing gear locked down and throttle advanced
48. A radar altimeter determines altitude by?
a. Means of a transponder interrogation
b. Receiving signals transmitted from a ground radar station
c. Transmitting a signal and receiving back a reflected signal
50. A fully integrated auto pilot controls the aircraft around how
many axis?
a. Four
b. Two
c. Three
52. What may be used to clean the surface of the deicer boots?
a. Unleaded gasoline or Jet Al fuel
b. Naptha
c. Soap and water