a. A foreign aviation authority b. A contracting state c. A civil aviation authority. 2. Anex for Licensing Aircraft, ATC, and AMEL a. Annex 1 b. Annex 6 c. Annex 8 3. What os definition of basic certificate a. certificate issued by dgca to person who has demonstrated an acceptable degree of competency b. certificate issued by dgca to person who passed the practical test c. certificate issued by dgca to person who passed the writing test 4. The person who make the following act is a basis for suspending or revoking any licensi or certificate and rating hold by the person accept a. Made by reproduction b. Lose licensing c. Made by alteration 5. Belum 6. Belum 7. In accordance with CASR 145, definition of capability list : a. A list of shop location b. A list of article on which the AMO rated c. A list of AMO rating 8. The person directly in charge is responsible for the work of a certificated AMO that perform maintenance with the following requirement, except: a. A person directly in charge need to physically & direct each worker b. A person directly in charge must be available for consultation on matters requiring instruction/decision from a higher authority c. A person designated as “directly in charge” must hold an appropriate license in accordance with CASR 65 9. Belum 10. The following parts are acceptable for installation on Indonesia registered aircraft, except: a. Part produce by Air Operator Certificates holders b. Part produce by Approved Maintenance Organization holders c. Part produce by Type Certificate holders 11. Belum 12. Belum 13. Rectangular fuel 60 in length 30 in width 12 in depth. Volume in ft^3 ? a. 12,5 b. 15 c. 21 14. Which is the ratio of the water vapor actually present in the atmosphere to the amount that would be present if the air were saturated at the prevailing temperature and pressure? a. Dew poimt b. Absolute humidity c. Relative humidity 15. Belum 16. Belum 17. Belum 18. Belum 19. what is class working drawing description single part? 20. Belum 21. Belum 22. Belum 23. What must be done to on instrument panel that supported by shock mounts ? a. Bonding straps must be installed across the instrument mounts as a current path. b. The instrument mounts must be grounded to the A/C structure as current path. c. Lali durung nulis 😂 24. Marking cover glass has slipped? a. Red b. White c. Yellow
25. Aircraft instrument should be marked and graduated in accordance with
a. The instrument manufacture's specifications b. Both the aircraft and engine manufacture's specifications c. The specific aircraft maintenance 26. Shock mount fucntion... 27. Belum 28. Belum 29. A/C instrument panels are generally shock mounted to absorb a. All vibration b. Low freq, high amp shocks c. High freq, hing amp shocks 30. When installing an instrument in an aircraft, who is responsible for making sure it is properly marked? a. The aircraft owner. b. The instrument installer. c. The instrument manufacturer. 31. Belum 32. The red radial lines on the face of an engine oil pressure gauge indicates a. minimum engine safe RPM operating range. b. minimum precautionary safe operating range c. minimum and/ or maximum safe operating limits 33. Belum 34. Belum 35. A radar altimeter indicates a. flight level (pressure) altitude b. altitude above sea level c. altitude above ground level 36. Which instruments are connected to an aircraft’s static pressure system only? a. Vertical speed indicator. b. Cabin altimeter. c. Altimeter. d. Cabin rate-of-change indicator. e. Airspeed indicator. a. 1,3 b. 2,4,5 c. 2,4 37. Belum 38. Belum 39. Belum 40. Belum flight level (pressure) altitude Eicas colour caution advisory message ? 41. Belum 42. Belum 43. Belum 44. If there a leak in the capsule of the airspeed indicator : a. Pointer give reading greater than actual ASI. b. Pointer give reading less than actual ASI. c. Instrument is unaffected by leakage. 45. Operation of ASI principle a. Expansion capsule to make baromatric pressure b. Dynamic pressure by balancing pitot against static pressure c. Rate of change barometric pressure through orifice 46. The position error of ASI reaches its max value when a. Fly at low AOA b. Fly at high AOA c. Crushing 47. Instrument pitot static system a. Altimeter, ASI, VSI, DGI b. Altimeter, ASI, VSI, Mach Number c. Altimeter, ASI, Rate of Climb, Machmeter 48. Belum 49. Belum 50. If the glass of atificial horizon broken, thus will cause failure of : a. Alt, directional gyro indicator, turn and bank indicator b. Magnetic compas, asi c. Directional gyro, artificial horizon, turn and bank indicator 51. In the mechanical type tachometer indicator, the force converted into indication is a. a centripetal force b. a rotational force c. a centrifugal force 52. Belum 53. which instruments belong to engine group a. Tachometer, oil temperature, Cylinder Head Temperature, Oil Pressure, Fuel Pressure. b. Tachometer, Cylinder Head Temperature, Fuel Gauge, Hydraulics Pressure, Directional Gyro Indicator c. Brake Pressure, Tachometer, Cylinder Head Temperature. Oil Temperature 54. belum 55. belum 56. belum 57. Face applied to the spin axis of gyro and tend to change the direction of the spin axis will ? a. Cause gyro axis to spin in the direction b. Transferred 90° against direction of rotation c. Transferred 90° in the direction of rotation 58. Aircraft climb higher altitude, bimetalic strip metering unit of VSI a. Close the valve b. Open the valve c. Stay close all the time 59. Belum 60. Belum 61. Belum 62. Belum 63. Mach trim treshold set by the? 64. What must be done to an instrument panel that is supported by shock mount? 65. Belum 66. Belum 67. What's the function of the ball indicator in turn coordinator ? a. To detect pitch movement the A/C. b. To detect wether the A/C is side-slipping during a turn. c. To detect breaking effect during A/C breaking prosses. 68. The operating mechanism of most hydraulic pressure gauges is a. Bourdon tube b. an evacuated bellows filled with an inert gas to which suitable arms, levers, and gears are attached. c. an airtight diaphragm. 69. What is the fix line max attached to the compass bowl of a magnetic a. Reference line b. Lubber line c. Reader line 70. Swiging compas, compensator are adjusted to correct... 71. Belum 72. Belum 73. What is the opposition on the flow of AC produced by magnetic field eith generated EMF called? a. Inductive reactance b. Capasitif reactance c. Mutual inductance 74. Electrostatic fields are also known as a. Dielectric fields b. Electrostatic fileds c. Static fields 75. Belum 76. The opposition offered by a coil to the flow of alternating current is called (disregard resistance) a. Impedance b. Reluctance c. inductive reactance 77. Belum 78. Belum 79. The amount of capacitor is directly proportional to the a. Distance between plate inversely b. Plate area not affected by distance between plate c. Plate area inversely proportional to the distance between plate 80. AC circuit effective V is ? a. Equal b. Greater c. Less 81. Belum 82. Belum 83. Belum 84. Belum 85. ELT power .... hours 86. Belum 87. Belum 88. Belum 89. Where the location of lighting strike areas in the A/C ? a. Radome, wing Leading edge, wing trailing edge, wing to body fairing, verical stab. b. Radome, wing Leading edge, wing trailing edge, wing to body fairing, engine. c. Radome, wing Leading edge, wing trailing edge, wing to body fairing, horizontal stab. 90. Cleaning procedure, there are three categories a. Personal, component, fire b. Personal, Aircraft, Fire c. Personal, Component, Wire 91. Personal protection during cleaning a. Aprons, boots, coveralls, neoprene gloves, rubber gloves, chemical googles, and approved eye b. Aprons, safety shoes, coveralls, neoprene gloves, cotton gloves, chemical googles, and approved eye c. Aprons, safety shoes, coveralls, neoprene gloves, leather gloves, chemical googles, and approved eye 92. Electrical shock occurs when the body becomes part of electricity this happen when individual comes in contact a. Both wire of electrical b. Wire di-energized and grounded c. A and B correct 93. Belum 94. Belum 95. Spring manufactired from a. High carbon, high strength b. Low carbon, high strength c. High carbon, low strength 96. A simple definition of human factors such as a. fitting the man to the job b. fitting the man to the environment c. fitting the man to the tools 97. Belum 98. Software in SHEL Model…. (contoh software) 99. Belum 100. Belum