Ene Paella ereclatterte
Instruction Manual
= Mounting Instructions
Brush away and clean out any foreign Remove the screw plug from the adapter
substances on the surface after verifying [P24 flange and adjust the position so that the
the size of the motor and the reducer. clamp bolt is noticable, (See “Appendix 1.)
When mounting onto the motor, closely adhere
the adapter flange of the reducer and the motor [&“j Bolts diagonally tighten based on the
mounting side and slightly tighten the clamping standard Ta, (See "Appendix 21)
bolt so that the clamp ring not idle,
Tighien the clamp ring based on the ighten the screw plug.
standard Tb, (See "Appendix 2.)Appendix 1
If the servo motor shaft does not have a round shape but key way, remove the key and make sure that the
key way of the servo motor shaft and the clamp bolt of the reducer input shaft can be perpendicular as
shown in'Fig, B.at mounting, Also, arrange each slot position of the Clamp Ring, the Gear Shaft, and the
Bushing in a line to get higher tightening power.
Clamp Bott
Bushing
Input Gear Shatt
Clamp
‘Motor Shaft
(Figure A) Round shaft (Figure B) Keyed shalt
Appendix 2) Bolt tightening torque
Bolt Size Motor mounting(8.8T)Ta Clamp ring(12,9T)Tb
Nem kgt-om Nem kgf+om
M3 128 13 215 2
M4 29 495 50
M5 575 97
M6 99 165
M8 24 40
Mio 48 8
M12 Ex} 140
M14 132
Mi6 200 ET)
® Appendix 3)) Cautions
Be careful of product handling
‘Be caretul not fo give an impact to the product wih a hammer end not to cause damage from a drop at handing
In case of the direct loading to the reducer, pay attention into the assembly.
‘Be caretul ol direct loading Such as concentnoly, peal evel, tension, etc, whenever connecting the product
‘othe load side such as a belt, a chain, ee,
Yeich out the sharp edges ofthe keyed shat. it may cause an injury
‘Do no ‘ouch or put athe foreign substances while itis being refed. may cause an injury
Do not give an impact to the product.
‘Be carelul ro! fo give an excessive impact whenever assembling a pulley, a coupling, a key, ec. tothe product
Do not exceed permissible torque at use.
Do nat give more than the interment permissible maximum torque may GaUSE roubles such as.bot loosen, rocking,
damage, and etc.
Do not disassemble the product.
‘Do nether dsassemble nor reassemble the product, Otherwise the manefacturer does ndt quarant
If any abnormal performance is detected, stop the operation,
‘F abnormal sound, vibration, abnormal heat or ec, Immediately slop the operation, Otherwise i may adversely
influence the sysiem.
(You can see our catalogue for more information)
P= ee ccd