Professional Documents
Culture Documents
SERVICE BULLETIN
CONF ALL
AIRBUS
2, ROND POINT EMILE DEWOITINE
31700 BLAGNAC
FRANCE
The content of this document is the property of Airbus. All rights including copyrights are reserved.
It is supplied in confidence and commercial security on its contents must be maintained.
It must not be used for any purpose other than that for which it is supplied, nor may information
contained in it be disclosed to unauthorized persons.
It must not be reproduced in whole or in part without permission in writing from the owners of the
copyright. Requests for reproduction of any data in this document and the media authorized for it must
be addressed to Airbus.
ATA SYSTEM: 34
SERVICE BULLETIN
General Sentence updated.
SUMMARY
APPLICABILITY Operator(s) updated.
CONCURRENT REQUIREMENTS Applicability updated.
PLANNING INFORMATION
APPLICABILITY
Configuration definition Aircraft added.
MODIFICATION CLASSIFICATION
MAJOR None
MINOR 153870P13147
NOTE: As per EASA IR 21, a minor change is one that has no appreciable effect on the
mass, balance, structural strength, reliability, operational characteristics affecting
the airworthiness of the product. All other changes are major changes.
B. REASON
(1) History
This Service Bulletin is issued further to an operator's request.
(2) Objective/Action
This Service Bulletin replaces the ACSS Traffic and Terrain Alert and Collision
Avoidance System (T2CAS) computer (FIN 100SG) PN 9000000-11313 by a new ACSS
T2CAS computer PN 9000000-11414.
The new TCAS computer Change 7.1 introduces the main software improvements:
EVALUATION TABLE
COMPLIANCE OPTIONAL COST SAVING NO
A/C OPERATION YES VENDOR SB YES
AFFECTED
CANCELS INSPECTION SB NO ETOPS AFFECTED NO
PAX COMFORT AFFECTED NO POTENTIAL AD NO
RELIABILITY AFFECTED NO STRUCTURAL LIFE EXTENSION NO
LIFE LIMIT NO LINE MAINTENANCE AFFECTED NO
EVALUATION TABLE
VALIDATION ON AIRCRAFT NO BOOKLET AVAILABLE NO
D. MAINTENANCE CONFIGURATION
No specific aircraft maintenance configuration required.
E. MATERIAL PRICE INFORMATION
(1) Modification of the Traffic and Terrain Alert and Collision Avoidance System
(T2CAS) Computer (100SG) by Vendor ACSS Service Bulletin No. 9000000-34-
6026 on bench.
(a) Task set A320-A-34-XX-1539-01000-93AA-A Modification of the Traffic and Terrain
Alert and Collision Avoidance System (T2CAS) Computer (100SG) by Vendor
ACSS Service Bulletin No. 9000000-34-6026 on bench.
No material
(2) Modification by Uploading of the Traffic and Terrain Alert and Collision
Avoidance System (T2CAS) Computer (100SG) by Vendor ACSS Service
Bulletin No 9000000-34-6026 on Aircraft.
(a) Task set A320-A-34-XX-1539-02000-93AA-A Modification by Uploading of the
Traffic and Terrain Alert and Collision Avoidance System (T2CAS) Computer
(100SG) by Vendor ACSS Service Bulletin No 9000000-34-6026 on Aircraft.
No material
(3) Modification by Replacement of the Traffic and Terrain Alert and Collision
Avoidance System (T2CAS) Computer (100SG) as per AMM.
(a) Task set A320-A-34-XX-1539-03000-93AA-A Modification by Replacement of
the Traffic and Terrain Alert and Collision Avoidance System (T2CAS) Computer
(100SG) as per AMM.
F. APPLICABILITY
This Service Bulletin is applicable to this (these) operator(s):
11S 33J 34L 41N 46L 48O 49N 78X 82W 83Q 86Z 90U 95W 96U A1L AAW AAY ABN ABQ ACA
AEE AHY AIJ ALK ASL AUA AWC AXM AZA BAV BEC BEL BGF BJN BKP BWJ CFG CTV DCS DKH
DRK EDW EVA EWE EWG EZY FHM G8E GCR GFA GJT GMI GOW GSW GWI HFM HYR IAD IGO
IRA IYE JAD JBW JCC JOC JZR KAY KME KNE LAO LBT LDA LZB MJN MKR MLM MMA MZT NMB
NWS OHY ORF PGT PIA PIC PVG QQE QTR RJA ROT RWZ SAS SDR SJV SLK SNG SSV SVA SVR
SVW TAP THY UAE UAL UEA UKN UNA VIV VJC VLG VOE VVC
G. CONCURRENT REQUIREMENTS
ON A/C 00345, 00364, 00385, 00445, 00466, 00537, 01132, 01162, 01179, 01244, 01308,
01322, 02254, 02310
Accomplishment of this Service Bulletin requires the prior or simultaneous accomplishment
of this/these Service Bulletin(s):
NOTE: Service Bulletin No. Ref. SB A320-34-1260 (NAVIGATION - ATC/MODE S - INSTALL L3-
COM ATC XS950 INCORPORATING EUROPEAN MODE S REGULATIONS).
ON A/C 01487, 01566, 01648, 01656, 01773, 01895, 01928, 01957, 02097, 02107, 02121,
02138, 02161, 02288, 02341
Accomplishment of this Service Bulletin requires the prior or simultaneous accomplishment
of this/these Service Bulletin(s):
ON A/C 01259, 02227, 02306, 02346, 02509, 02517, 02539, 02566, 02568, 02612, 02619,
02631, 02633, 02648, 02654-02656, 02660, 02683, 02685, 02696, 02699, 02760, 02816,
02820, 02826, 02835, 02842, 02844, 02846, 02853, 02863, 02865, 02869, 02879, 02881,
02883, 02885, 02911, 02913, 02926, 02931, 02932, 02944, 02955, 02956, 02958, 02968,
02975, 02989-02991, 02995, 03000, 03006, 03018, 03021, 03027, 03046, 03055, 03064,
03071, 03076, 03079, 03080, 03086, 03093, 03100, 03115, 03117, 03121, 03139, 03140,
03142, 03149, 03154, 03159, 03160, 03173, 03178, 03182, 03188, 03192, 03194, 03199,
03201, 03202, 03213, 03220, 03223-03225, 03227, 03232, 03234, 03236, 03238, 03242,
03243, 03245, 03256, 03259, 03260, 03264, 03268, 03274, 03277, 03286, 03289, 03291,
03295, 03299, 03306, 03308, 03309, 03312, 03327, 03328, 03330, 03333, 03335, 03338,
03343, 03346, 03353, 03356, 03357, 03362-03364, 03368, 03370, 03374, 03382, 03385,
03388, 03394, 03397, 03403, 03404, 03412, 03414, 03415, 03421, 03424, 03427, 03447,
03448, 03453, 03454, 03457, 03464, 03477, 03482, 03484-03486, 03489, 03497, 03502,
03505, 03508, 03514, 03515, 03519, 03521, 03530, 03532, 03533, 03536, 03541, 03546,
03549, 03560, 03563, 03564, 03568, 03570, 03575, 03576, 03582, 03586, 03589, 03596-
03598, 03604, 03605, 03609, 03610, 03614-03616, 03618, 03628, 03636, 03643, 03657,
ON A/C 03985
Accomplishment of this Service Bulletin requires the prior or simultaneous accomplishment
of this/these Service Bulletin(s):
NOTE: Service Bulletin No. Ref. SB A320-34-1342 (NAVIGATION - ATC - REMOVE COLLINS
TPR901 ATC MODE-S TRANSPONDERS (-021)).
ON A/C 05013, 05071, 05080, 05089, 05131, 05137, 05149, 05153, 05163, 05200, 05215,
05226, 05272, 05283, 05325, 05329, 05339, 05344, 05347, 05353, 05359, 05431
Accomplishment of this Service Bulletin requires the prior or simultaneous accomplishment
of this/these Service Bulletin(s):
(1) Modification of the Traffic and Terrain Alert and Collision Avoidance System
(T2CAS) Computer (100SG) by Vendor ACSS Service Bulletin No. 9000000-34-
6026 on bench.
(a) Task set A320-A-34-XX-1539-01000-93AA-A Modification of the Traffic and Terrain
Alert and Collision Avoidance System (T2CAS) Computer (100SG) by Vendor
ACSS Service Bulletin No. 9000000-34-6026 on bench.
AIRCRAFT NO
EQUIPMENT YES
(2) Modification by Uploading of the Traffic and Terrain Alert and Collision
Avoidance System (T2CAS) Computer (100SG) by Vendor ACSS Service
Bulletin No 9000000-34-6026 on Aircraft.
(a) Task set A320-A-34-XX-1539-02000-93AA-A Modification by Uploading of the
Traffic and Terrain Alert and Collision Avoidance System (T2CAS) Computer
(100SG) by Vendor ACSS Service Bulletin No 9000000-34-6026 on Aircraft.
AIRCRAFT NO
EQUIPMENT YES
(3) Modification by Replacement of the Traffic and Terrain Alert and Collision
Avoidance System (T2CAS) Computer (100SG) as per AMM.
(a) Task set A320-A-34-XX-1539-03000-93AA-A Modification by Replacement of
the Traffic and Terrain Alert and Collision Avoidance System (T2CAS) Computer
(100SG) as per AMM.
AIRCRAFT NO
EQUIPMENT YES
I. MANPOWER
(1) Modification of the Traffic and Terrain Alert and Collision Avoidance System
(T2CAS) Computer (100SG) by Vendor ACSS Service Bulletin No. 9000000-34-
6026 on bench.
(a) Task set A320-A-34-XX-1539-01000-93AA-A Modification of the Traffic and Terrain
Alert and Collision Avoidance System (T2CAS) Computer (100SG) by Vendor
ACSS Service Bulletin No. 9000000-34-6026 on bench.
MANPOWER
TOTAL MAN-HOURS 2.50 h
ELAPSED TIME (HOURS) 2.50 h
Additional man-hours related to Vendor SB; refer to:
Modify the Traffic and Terrain Alert and Ref. ACSS (1WYD3) VSB 9000000- BENCH
Collision Avoidance System (T2CAS) 34-6026
Computer (100SG)
(2) Modification by Uploading of the Traffic and Terrain Alert and Collision
Avoidance System (T2CAS) Computer (100SG) by Vendor ACSS Service
Bulletin No 9000000-34-6026 on Aircraft.
MANPOWER
TOTAL MAN-HOURS 1.50 h
ELAPSED TIME (HOURS) 1.50 h
Additional man-hours related to Vendor SB; refer to:
In the AFT Electronics Rack 80VU, Ref. ACSS (1WYD3) VSB 9000000-34-6026
Upload the Traffic and Terrain Alert and
Collision Avoidance System (T2CAS)
Computer (100SG)
(3) Modification by Replacement of the Traffic and Terrain Alert and Collision
Avoidance System (T2CAS) Computer (100SG) as per AMM.
(a) Task set A320-A-34-XX-1539-03000-93AA-A Modification by Replacement of
the Traffic and Terrain Alert and Collision Avoidance System (T2CAS) Computer
(100SG) as per AMM.
MANPOWER
TOTAL MAN-HOURS 2.50 h
ELAPSED TIME (HOURS) 2.50 h
FR24A
Z120
FR1
100SG
A
80VU
ICN-A320-A-34XX1539-A-FAPE3-009LV-A-001-01
ATA SYSTEM: 34
03978, 03997, 04019, 04035, 04070, 04075, 04088, 04098, 04108, 04119, 04126, 04143,
04147, 04152, 04195, 04249, 04278, 04302, 04333, 04346, 04361, 04367, 04386, 04390,
04404, 04426, 04458, 04462, 04477, 04486, 04520, 04523, 04536, 04557, 04571, 04582,
04793, 04797, 04807, 04882, 04889, 04969, 04979, 04980, 04989, 05137, 05149, 05215,
05272, 05283, 05347, 05353, 05359, 05431
320-216
ON A/C 01566, 01648, 01773, 01895, 01957, 02097, 02121, 02138, 02161, 02254, 02288,
02310, 02509, 02517, 02566, 02844, 02863, 02883, 02911, 02958, 02990, 03071, 03086,
03159, 03192, 03227, 03259, 03264, 03308, 03330, 03335, 03357, 03414, 03453, 03457,
03484, 03497, 03519, 03541, 03618, 03782, 03863, 03943, 04008, 04113, 04156, 04170,
04216, 04312, 04328, 04384, 04481, 04488, 04506, 04518, 04535, 04552, 04603, 04609,
04614, 04630, 04637, 04752, 04757, 04762, 04813, 04818, 04868, 04888, 04947, 04954,
04965, 05027, 05036, 05076, 05080, 05090, 05092, 05094
320-232
ON A/C 03570, 04118, 04457, 04653, 04690, 04701, 05050, 05089
320-233
ON A/C 00364, 00385
321-131
ON A/C 03708, 03749, 04334, 04467, 04542, 04577, 04590, 04728, 04811, 04838, 04925,
04962, 05009, 05038, 05065
321-211
ON A/C 01487, 01928, 02107, 03274, 03382, 03397, 03546, 03575, 03636, 05025, 05074
321-231
CONF ALL
(2) Applicability by MSN
00345 00364 00385 00445 00466 00537 01132 01162 01179 01244 01259 01308
01322 01487 01566 01648 01656 01773 01895 01928 01957 02097 02107 02121
02138 02161 02227 02254 02288 02306 02310 02341 02346 02509 02517 02539
02566 02568 02612 02619 02631 02633 02648 02654-02656 02660 02683 02685
02696 02699 02760 02816 02820 02826 02835 02842 02844 02846 02853 02863
02865 02869 02879 02881 02883 02885 02911 02913 02926 02931 02932 02944
02955 02956 02958 02968 02975 02989-02991 02995 03000 03006 03018 03021
03027 03046 03055 03064 03071 03076 03079 03080 03086 03093 03100 03115
03117 03121 03139 03140 03142 03149 03154 03159 03160 03173 03178 03182
03188 03192 03194 03199 03201 03202 03213 03220 03223-03225 03227 03232
03234 03236 03238 03242 03243 03245 03256 03259 03260 03264 03268 03274
03277 03286 03289 03291 03295 03299 03306 03308 03309 03312 03327 03328
03330 03333 03335 03338 03343 03346 03353 03356 03357 03362-03364 03368
03370 03374 03382 03385 03388 03394 03397 03403 03404 03412 03414 03415
03421 03424 03427 03447 03448 03453 03454 03457 03464 03477 03482 03484-
03486 03489 03497 03502 03505 03508 03514 03515 03519 03521 03530 03532
03533 03536 03541 03546 03549 03560 03563 03564 03568 03570 03575 03576
03582 03586 03589 03596-03598 03604 03605 03609 03610 03614-03616 03618
03628 03636 03643 03657 03661 03666 03667 03679 03689 03690 03694 03695
03700 03701 03704 03708 03715 03723 03728 03729 03732 03739 03749 03751
03758 03759 03765 03769 03776 03782 03791 03798 03813 03815 03818 03827
03831 03833 03846 03853 03861 03863 03865 03872 03875 03883 03885 03895
03896 03900 03906 03907 03911 03915 03921 03931 03932 03943 03945 03949
03950 03956 03963 03967 03976 03978 03984 03985 03995 03997 04004 04008
04013 04015 04019 04021 04030 04033 04035 04049 04055 04057 04059 04064
04070 04075 04079 04081 04083 04088 04090 04092 04095 04098 04101 04102
04104 04106 04108 04113-04115 04117-04119 04122 04126 04128 04135 04143
04145-04147 04152 04154 04156 04158 04161 04169 04170 04187 04188 04190
REV 00 Aug 09/12 A320-34-1539
REV 39 Mar 18/21 Page 14
A318/A319/A320/A321
SERVICE BULLETIN
04193 04195 04199 04203 04207 04211 04215 04216 04218 04228 04235 04249
04255 04259 04263 04268 04269 04273 04276 04278 04282 04291 04293 04294
04301 04302 04304 04312 04314 04328 04329 04333 04334 04337 04346 04349
04357 04361 04364 04367 04376 04384 04386 04390-04394 04397 04399 04401
04404 04408 04411 04414 04419 04426 04429 04432 04433 04438 04442 04454
04457 04458 04462 04463 04467 04477 04478 04481 04484 04486 04488 04489
04501-04503 04506 04510 04517-04521 04523 04535 04536 04542 04552 04557
04564 04565 04571 04573 04577 04582 04587 04589 04590 04596 04600 04603
04606 04609 04614 04622 04630 04631 04637 04639 04652 04653 04674 04675
04690 04701 04728 04730 04733 04743 04752 04757 04759 04762 04764 04793
04795 04797 04807 04811 04813 04818 04822 04823 04833 04838 04840 04842
04859 04868 04875 04882 04888 04889 04910 04917 04924 04925 04933 04947
04954-04956 04962 04964 04965 04969 04979-04981 04988 04989 04992 05009
05013 05016 05018 05025 05027 05036 05038 05050 05065 05070 05071 05074
05076 05080 05089 05090 05092 05094 05131 05137 05149 05153 05163 05200
05215 05226 05272 05283 05325 05329 05339 05344 05347 05353 05359 05431
(3) MSN by configuration
MSN CONFIGURATION
00345 00364 00385 00445 00466 00537 01132 01162 01179 001
01244 01259 01308 01322 01487 01566 01648 01656 01773
01895 01928 01957 02097 02107 02121 02138 02161 02227
02254 02288 02306 02310 02341 02346 02509 02517 02539
02566 02568 02612 02619 02631 02633 02648 02654 02655
02656 02660 02683 02685 02696 02699 02760 02816 02820
02826 02835 02842 02844 02846 02853 02863 02865 02869
02879 02881 02883 02885 02911 02913 02926 02931 02932
02944 02955 02956 02958 02968 02975 02989 02990 02991
02995 03000 03006 03018 03021 03027 03046 03055 03064
03071 03076 03079 03080 03086 03093 03100 03115 03117
03121 03139 03140 03142 03149 03154 03159 03160 03173
03178 03182 03188 03192 03194 03199 03201 03202 03213
03220 03223 03224 03225 03227 03232 03234 03236 03238
03242 03243 03245 03256 03259 03260 03264 03268 03274
03277 03286 03289 03291 03295 03299 03306 03308 03309
03312 03327 03328 03330 03333 03335 03338 03343 03346
03353 03356 03357 03362 03363 03364 03368 03370 03374
03382 03385 03388 03394 03397 03403 03404 03412 03414
03415 03421 03424 03427 03447 03448 03453 03454 03457
03464 03477 03482 03484 03485 03486 03489 03497 03502
03505 03508 03514 03515 03519 03521 03530 03532 03533
03536 03541 03546 03549 03560 03563 03564 03568 03570
03575 03576 03582 03586 03589 03596 03597 03598 03604
03605 03609 03610 03614 03615 03616 03618 03628 03636
03643 03657 03661 03666 03667 03679 03689 03690 03694
03695 03700 03701 03704 03708 03715 03723 03728 03729
03732 03739 03749 03751 03758 03759 03765 03769 03776
03782 03791 03798 03813 03815 03818 03827 03831 03833
03846 03853 03861 03863 03865 03872 03875 03883 03885
03895 03896 03900 03906 03907 03911 03915 03921 03931
03932 03943 03945 03949 03950 03956 03963 03967 03976
03978 03984 03985 03995 03997 04004 04008 04013 04015
04019 04021 04030 04033 04035 04049 04055 04057 04059
04064 04070 04075 04079 04081 04083 04088 04090 04092
04095 04098 04101 04102 04104 04106 04108 04113 04114
MSN CONFIGURATION
04115 04117 04118 04119 04122 04126 04128 04135 04143
04145 04146 04147 04152 04154 04156 04158 04161 04169
04170 04187 04188 04190 04193 04195 04199 04203 04207
04211 04215 04216 04218 04228 04235 04249 04255 04259
04263 04268 04269 04273 04276 04278 04282 04291 04293
04294 04301 04302 04304 04312 04314 04328 04329 04333
04334 04337 04346 04349 04357 04361 04364 04367 04376
04384 04386 04390 04391 04392 04393 04394 04397 04399
04401 04404 04408 04411 04414 04419 04426 04429 04432
04433 04438 04442 04454 04457 04458 04462 04463 04467
04477 04478 04481 04484 04486 04488 04489 04501 04502
04503 04506 04510 04517 04518 04519 04520 04521 04523
04535 04536 04542 04552 04557 04564 04565 04571 04573
04577 04582 04587 04589 04590 04596 04600 04603 04606
04609 04614 04622 04630 04631 04637 04639 04652 04653
04674 04675 04690 04701 04728 04730 04733 04743 04752
04757 04759 04762 04764 04793 04795 04797 04807 04811
04813 04818 04822 04823 04833 04838 04840 04842 04859
04868 04875 04882 04888 04889 04910 04917 04924 04925
04933 04947 04954 04955 04956 04962 04964 04965 04969
04979 04980 04981 04988 04989 04992 05009 05013 05016
05018 05025 05027 05036 05038 05050 05065 05070 05071
05074 05076 05080 05089 05090 05092 05094 05131 05137
05149 05153 05163 05200 05215 05226 05272 05283 05325
05329 05339 05344 05347 05353 05359 05431
(4) Configuration definition
Configuration 001
CONF 001 is applicable for all the aircraft affected by this Service Bulletin as a
standard configuration. Bulletin as a standard configuration.
CONF 001 retrofits following modifications: 153870P13147.
B. CONCURRENT REQUIREMENTS
ON A/C 00345, 00364, 00385, 00445, 00466, 00537, 01132, 01162, 01179, 01244, 01308,
01322, 02254, 02310
Accomplishment of this Service Bulletin requires the prior or simultaneous accomplishment
of this/these Service Bulletin(s):
NOTE: Service Bulletin No. Ref. SB A320-34-1260 (NAVIGATION - ATC/MODE S - INSTALL L3-
COM ATC XS950 INCORPORATING EUROPEAN MODE S REGULATIONS).
ON A/C 01487, 01566, 01648, 01656, 01773, 01895, 01928, 01957, 02097, 02107, 02121,
02138, 02161, 02288, 02341
Accomplishment of this Service Bulletin requires the prior or simultaneous accomplishment
of this/these Service Bulletin(s):
ON A/C 01259, 02227, 02306, 02346, 02509, 02517, 02539, 02566, 02568, 02612, 02619,
02631, 02633, 02648, 02654-02656, 02660, 02683, 02685, 02696, 02699, 02760, 02816,
02820, 02826, 02835, 02842, 02844, 02846, 02853, 02863, 02865, 02869, 02879, 02881,
02883, 02885, 02911, 02913, 02926, 02931, 02932, 02944, 02955, 02956, 02958, 02968,
02975, 02989-02991, 02995, 03000, 03006, 03018, 03021, 03027, 03046, 03055, 03064,
03071, 03076, 03079, 03080, 03086, 03093, 03100, 03115, 03117, 03121, 03139, 03140,
03142, 03149, 03154, 03159, 03160, 03173, 03178, 03182, 03188, 03192, 03194, 03199,
03201, 03202, 03213, 03220, 03223-03225, 03227, 03232, 03234, 03236, 03238, 03242,
03243, 03245, 03256, 03259, 03260, 03264, 03268, 03274, 03277, 03286, 03289, 03291,
03295, 03299, 03306, 03308, 03309, 03312, 03327, 03328, 03330, 03333, 03335, 03338,
03343, 03346, 03353, 03356, 03357, 03362-03364, 03368, 03370, 03374, 03382, 03385,
03388, 03394, 03397, 03403, 03404, 03412, 03414, 03415, 03421, 03424, 03427, 03447,
03448, 03453, 03454, 03457, 03464, 03477, 03482, 03484-03486, 03489, 03497, 03502,
03505, 03508, 03514, 03515, 03519, 03521, 03530, 03532, 03533, 03536, 03541, 03546,
03549, 03560, 03563, 03564, 03568, 03570, 03575, 03576, 03582, 03586, 03589, 03596-
03598, 03604, 03605, 03609, 03610, 03614-03616, 03618, 03628, 03636, 03643, 03657,
03661, 03666, 03667, 03679, 03689, 03690, 03694, 03695, 03700, 03701, 03704, 03708,
03715, 03723, 03728, 03729, 03732, 03739, 03749, 03751, 03758, 03759, 03765, 03769,
03776, 03782, 03791, 03798, 03813, 03815, 03818, 03827, 03831, 03833, 03846, 03853,
03861, 03863, 03865, 03872, 03875, 03883, 03885, 03895, 03896, 03900, 03906, 03907,
03911, 03915, 03921, 03931, 03932, 03943, 03945, 03949, 03950, 03956, 03963, 03967,
03976, 03978, 03984, 03995, 03997, 04004, 04008, 04013, 04015, 04019, 04021, 04030,
04033, 04035, 04049, 04055, 04057, 04059, 04064, 04070, 04075, 04079, 04081, 04083,
04088, 04090, 04092, 04095, 04098, 04101, 04102, 04104, 04106, 04108, 04113-04115,
04117-04119, 04122, 04126, 04128, 04135, 04143, 04145-04147, 04152, 04154, 04156,
04158, 04161, 04169, 04170, 04187, 04188, 04190, 04193, 04195, 04199, 04203, 04207,
04211, 04215, 04216, 04218, 04228, 04235, 04249, 04255, 04259, 04263, 04268, 04269,
04273, 04276, 04278, 04282, 04291, 04293, 04294, 04301, 04302, 04304, 04312, 04314,
04328, 04329, 04333, 04334, 04337, 04346, 04349, 04357, 04361, 04364, 04367, 04376,
04384, 04386, 04390-04394, 04397, 04399, 04401, 04404, 04408, 04411, 04414, 04419,
04426, 04429, 04432, 04433, 04438, 04442, 04454, 04457, 04458, 04462, 04463, 04467,
04477, 04478, 04481, 04484, 04486, 04488, 04489, 04501-04503, 04506, 04510, 04517-
04521, 04523, 04535, 04536, 04542, 04552, 04557, 04564, 04565, 04571, 04573, 04577,
04582, 04587, 04589, 04590, 04596, 04600, 04603, 04606, 04609, 04614, 04622, 04630,
04631, 04637, 04639, 04652, 04653, 04674, 04675, 04690, 04701, 04728, 04730, 04733,
04743, 04752, 04757, 04759, 04762, 04764, 04793, 04795, 04797, 04807, 04811, 04813,
04818, 04822, 04823, 04833, 04838, 04840, 04842, 04859, 04868, 04875, 04882, 04888,
04889, 04910, 04917, 04924, 04925, 04933, 04947, 04954-04956, 04962, 04964, 04965,
04969, 04979-04981, 04988, 04989, 04992, 05009, 05016, 05018, 05025, 05027, 05036,
05038, 05050, 05065, 05070, 05074, 05076, 05090, 05092, 05094
Accomplishment of this Service Bulletin requires the prior or simultaneous accomplishment
of this/these Service Bulletin(s):
ON A/C 03985
Accomplishment of this Service Bulletin requires the prior or simultaneous accomplishment
of this/these Service Bulletin(s):
NOTE: Service Bulletin No. Ref. SB A320-34-1342 (NAVIGATION - ATC - REMOVE COLLINS
TPR901 ATC MODE-S TRANSPONDERS (-021)).
ON A/C 05013, 05071, 05080, 05089, 05131, 05137, 05149, 05153, 05163, 05200, 05215,
05226, 05272, 05283, 05325, 05329, 05339, 05344, 05347, 05353, 05359, 05431
Accomplishment of this Service Bulletin requires the prior or simultaneous accomplishment
of this/these Service Bulletin(s):
(1) History
This Service Bulletin is issued further to an operator's request.
(2) Objective/Action
This Service Bulletin replaces the ACSS Traffic and Terrain Alert and Collision
Avoidance System (T2CAS) computer (FIN 100SG) PN 9000000-11313 by a new ACSS
T2CAS computer PN 9000000-11414.
The new TCAS computer Change 7.1 introduces the main software improvements:
D. DESCRIPTION
(1) Classification
OPTIONAL: Service Bulletin for convenience or option.
(2) Accomplishment Timescale
In accordance with operators' maintenance schedule.
F. APPROVAL
The technical content of this document is approved under the authority of the Design
Organisation Approval ref. EASA.21J.031.
If an aircraft listed in the applicability has a modification or repair embodied that is not
of AIRBUS origin, and which affects the content of this Service Bulletin, the operator
is responsible for obtaining approval by its airworthiness authority for any adaptation
necessary before incorporation of the Service Bulletin.
G. MANPOWER
The manpower estimates given in this Service Bulletin are based on the direct labor cost to
do the work. These estimates assume that the work will be done by experienced personnel,
and may need to be revised upwards to suit operator’s circumstances. The estimates do not
include the time to prepare, plan or inspect the work. Manufacture and procurement of parts
and tools, drying times for paints, sealants, etc., and general administration work are also
not included.
(1) Modification of the Traffic and Terrain Alert and Collision Avoidance System
(T2CAS) Computer (100SG) by Vendor ACSS Service Bulletin No. 9000000-34-
6026 on bench.
(a) Task set A320-A-34-XX-1539-01000-93AA-A Modification of the Traffic and Terrain
Alert and Collision Avoidance System (T2CAS) Computer (100SG) by Vendor
ACSS Service Bulletin No. 9000000-34-6026 on bench.
PREPARATION
Job Set-up 0.50 h
PROCEDURE
In the AFT Electronics Rack 80VU, Remove the Traffic and 0.50 h
Terrain Alert and Collision Avoidance System (T2CAS)
Computer (100SG)
In the AFT Electronics Rack 80VU, Install the Traffic and 0.50 h
Terrain Alert and Collision Avoidance System (T2CAS)
Computer (100SG)
PREPARATION FOR TEST
Test Job Set-up 0.25 h
TEST
Test 0.25 h
CLOSE-UP
Close-up 0.50 h
TOTAL MAN-HOURS 2.50 h
ELAPSED TIME (HOURS) 2.50 h
Additional man-hours related to Vendor SB; refer to:
Modify the Traffic and Terrain Alert and Ref. ACSS (1WYD3) VSB 9000000- BENCH
Collision Avoidance System (T2CAS) 34-6026
Computer (100SG)
(2) Modification by Uploading of the Traffic and Terrain Alert and Collision
Avoidance System (T2CAS) Computer (100SG) by Vendor ACSS Service
Bulletin No 9000000-34-6026 on Aircraft.
(a) Task set A320-A-34-XX-1539-02000-93AA-A Modification by Uploading of the
Traffic and Terrain Alert and Collision Avoidance System (T2CAS) Computer
(100SG) by Vendor ACSS Service Bulletin No 9000000-34-6026 on Aircraft.
PREPARATION
Job Set-up 0.50 h
PROCEDURE
PREPARATION FOR TEST
None
TEST
Test 0.50 h
CLOSE-UP
Close-up 0.50 h
TOTAL MAN-HOURS 1.50 h
ELAPSED TIME (HOURS) 1.50 h
Additional man-hours related to Vendor SB; refer to:
In the AFT Electronics Rack 80VU, Ref. ACSS (1WYD3) VSB 9000000-34-6026
Upload the Traffic and Terrain Alert and
Collision Avoidance System (T2CAS)
Computer (100SG)
(3) Modification by Replacement of the Traffic and Terrain Alert and Collision
Avoidance System (T2CAS) Computer (100SG) as per AMM.
(a) Task set A320-A-34-XX-1539-03000-93AA-A Modification by Replacement of
the Traffic and Terrain Alert and Collision Avoidance System (T2CAS) Computer
(100SG) as per AMM.
PREPARATION
Job Set-up 0.50 h
PROCEDURE
In the AFT Electronics Rack 80VU, Replace the Traffic and 1.00 h
Terrain Alert and Collision Avoidance System (T2CAS)
Computer (100SG)
PREPARATION FOR TEST
Test Job Set-up 0.25 h
TEST
Procedure 0.25 h
CLOSE-UP
Close-up 0.50 h
TOTAL MAN-HOURS 2.50 h
ELAPSED TIME (HOURS) 2.50 h
H. WEIGHT AND BALANCE
Not changed
I. ELECTRICAL LOAD DATA
Not changed
J. REFERENCES
ON A/C 00345, 00364, 00385, 00445, 00466, 00537, 01132, 01162, 01179, 01244, 01308,
01322, 02254, 02310
(1) Modification of the Traffic and Terrain Alert and Collision Avoidance System
(T2CAS) Computer (100SG) by Vendor ACSS Service Bulletin No. 9000000-34-
6026 on bench.
(a) Task set A320-A-34-XX-1539-01000-93AA-A Modification of the Traffic and Terrain
Alert and Collision Avoidance System (T2CAS) Computer (100SG) by Vendor
ACSS Service Bulletin No. 9000000-34-6026 on bench.
(3) Modification by Replacement of the Traffic and Terrain Alert and Collision
Avoidance System (T2CAS) Computer (100SG) as per AMM.
(a) Task set A320-A-34-XX-1539-03000-93AA-A Modification by Replacement of
the Traffic and Terrain Alert and Collision Avoidance System (T2CAS) Computer
(100SG) as per AMM.
2. MATERIAL INFORMATION
A. MATERIAL APPLICABILITY
Material for task set A320-A-34-XX-1539-01000-93AA-A Modification of the Traffic
and Terrain Alert and Collision Avoidance System (T2CAS) Computer (100SG) by
Vendor ACSS Service Bulletin No. 9000000-34-6026 on bench.
Procurement address
NOTE(S)
Sales terms must be agreed between the Customer and AIRBUS in accordance with
the RFC (or RFC/RMO) procedure.
Equipment procurement conditions are defined in the commercial offer. For any
assistance, Airline Customers are requested to contact:
ITEM NEW PART No. KEYWORD ITEM OLD PART No. SEE NOTES
9000000-11414 COMPUTER 9000000-11313
Re-identified parts for task set A320-A-34-XX-1539-02000-93AA-A Modification
by Uploading of the Traffic and Terrain Alert and Collision Avoidance System
(T2CAS) Computer (100SG) by Vendor ACSS Service Bulletin No 9000000-34-6026
on Aircraft.
ITEM NEW PART No. KEYWORD ITEM OLD PART No. SEE NOTES
9000000-11414 COMPUTER 9000000-11313
Interchangeable parts for task set A320-A-34-XX-1539-01000-93AA-A Modification
of the Traffic and Terrain Alert and Collision Avoidance System (T2CAS) Computer
(100SG) by Vendor ACSS Service Bulletin No. 9000000-34-6026 on bench.
DESCRIPTION OLD PART No. NEW PART No. INT SEE NOTES
COMPUTER-T2CAS 9000000-11313 9000000-11414 03
NOTE(S)
For definitions of interchangeability codes in column INT. refer to ATA (CSDD Chapter
2).
Interchangeable parts for task set A320-A-34-XX-1539-02000-93AA-A Modification
by Uploading of the Traffic and Terrain Alert and Collision Avoidance System
(T2CAS) Computer (100SG) by Vendor ACSS Service Bulletin No 9000000-34-6026
on Aircraft.
DESCRIPTION OLD PART No. NEW PART No. INT SEE NOTES
COMPUTER-T2CAS 9000000-11313 9000000-11414 03
NOTE(S)
For definitions of interchangeability codes in column INT. refer to ATA (CSDD Chapter
2).
Interchangeable parts for task set A320-A-34-XX-1539-03000-93AA-A Modification
by Replacement of the Traffic and Terrain Alert and Collision Avoidance System
(T2CAS) Computer (100SG) as per AMM.
DESCRIPTION OLD PART No. NEW PART No. INT SEE NOTES
COMPUTER-T2CAS 9000000-11313 9000000-11414 03
NOTE(S)
For definitions of interchangeability codes in column INT. refer to ATA (CSDD Chapter
2).
Spare parts for task set A320-A-34-XX-1539-03000-93AA-A Modification by
Replacement of the Traffic and Terrain Alert and Collision Avoidance System
(T2CAS) Computer (100SG) as per AMM.
3. ACCOMPLISHMENT INSTRUCTIONS
Task set A320-A-34-XX-1539-01000-93AA-A (A320-A-34-XX-1539-01ZZZ-93AZ-A)
Modification of the Traffic and Terrain Alert and Collision Avoidance System (T2CAS) Computer
(100SG) by Vendor ACSS Service Bulletin No. 9000000-34-6026 on bench.
WARNING: MAKE SURE THAT YOU OBEY ALL THE WARNINGS AND ALL THE CAUTIONS
INCLUDED IN THE REFERENCED PROCEDURES.
NOTE: The accomplishment instructions of this Service Bulletin include procedures given in
other documents or in other sections of the Service Bulletin. When the words “refer to”
are used and the operator has a procedure accepted by the local authority he belongs to,
the accepted alternative procedure can be used. When the words “in accordance with”
are used then the given procedure must be followed.
NOTE: The access and close-up instructions, not comprising return to service tests, in this
Service Bulletin do not constitute or affect the technical intent of the Service Bulletin.
Operators can therefore, as deemed necessary, omit or add access and/or close-up steps
to add flexibility to their maintenance operations as long as the technical intent of the
Service Bulletin is met within the set parameters.
NOTE: Manual titles given in the accomplishment instructions are referred to by acronyms. Refer
to paragraph 1.J., References, for the definition of acronyms.
NOTE: This Service Bulletin contains the instructions for the on-aircraft maintenance necessary
to ensure the continued airworthiness of the aircraft.
For any deviations to the instructions, contact AIRBUS for further instructions and
approval.
Man-hours 0.50 h
Minimum Number of person 1
Referenced Information
Manuals/Drawings References/Sheets
Task 12-34-24-869-002
AMM Task 34-43-34-000-004
Task 52-10-00-010-001
Procedure
NOTE: For the basic Aircraft configuration, refer to AMM Chapter “Introduction -
Aircraft status for maintenance" in Manual Front Matter section.
(a) Make sure that the aircraft is electrically grounded, refer to Ref. AMM Task 12-34-
24-869-002.
(b) Put the access platform(s) in position.
(c) Open the FWD passenger/crew door 831, refer to Ref. AMM Task 52-10-00-010-
001.
(d) Do the Job Set-up procedure as specified in the removal of the Traffic and Terrain
Alert and Collision Avoidance System (T2CAS) computer (FIN 100SG), refer to
Ref. AMM Task 34-43-34-000-004.
C. PROCEDURE
(1) Task A320-A-34-XX-1539-01001-520A-A (A320-A-34-XX-1539-01ZZZ-520Z-A)
In the AFT Electronics Rack 80VU, Remove the Traffic and Terrain Alert and
Collision Avoidance System (T2CAS) Computer (100SG)
Job Set-Up Information
Working Area
Man-hours 0.50 h
Minimum Number of person 1
Elapsed Time 0.50 h
Material necessary to do the job
Re-identified Part Set
ITEM NEW PART No. KEYWORD ITEM OLD PART No. SEE NOTES
9000000-11414 COMPUTER 9000000-11313
Referenced Information
Manuals/Drawings References/Sheets
Task 20-16-00-912-001
AMM
Task 34-43-34-000-004
Procedure
FIN 100SG
1 COMPUTER-T2CAS 9000000-11313 Retain
Manuals/Drawings References/Sheets
VSB ACSS (1WYD3) VSB 9000000-34-6026
Procedure
(a) Modify the T2CAS Computer (FIN 100SG) in accordance with Ref. ACSS (1WYD3)
VSB 9000000-34-6026.
(b) After the modification:
FIN 100SG
1 COMPUTER-T2CAS 9000000-11313
Becomes
FIN 100SG
1 COMPUTER-T2CAS 9000000-11414
(3) Task A320-A-34-XX-1539-01001-720A-A (A320-A-34-XX-1539-01ZZZ-720Z-A)
In the AFT Electronics Rack 80VU, Install the Traffic and Terrain Alert and
Collision Avoidance System (T2CAS) Computer (100SG)
Job Set-Up Information
Working Area
Man-hours 0.50 h
Minimum Number of person 1
Manuals/Drawings References/Sheets
AMM Task 34-43-34-400-004
Procedure
(a) Install the modified T2CAS:
Refer to Ref. AMM Task 34-43-34-400-004
FIN 100SG
1 COMPUTER-T2CAS 9000000-11414
D. PREPARATION FOR TEST
(1) Task A320-A-34-XX-1539-01001-92AA-A (A320-A-34-XX-1539-01ZZZ-92AZ-A)
Test Job Set-up
Job Set-Up Information
Manpower/Resources/Skills
Man-hours 0.25 h
Minimum Number of person 1
Elapsed Time 0.25 h
Referenced Information
Manuals/Drawings References/Sheets
AMM Task 34-43-34-400-004
Procedure
(a) Remove the safety clips and/or tags and close/unlock the circuit breakers as
specified after the installation of the Traffic and Terrain Alert and Collision
Avoidance System (T2CAS) Computer (FIN 100SG), refer to Ref. AMM Task 34-43-
34-400-004.
E. TEST
(1) Task A320-A-34-XX-1539-01001-390A-A (A320-A-34-XX-1539-01ZZZ-390Z-A)
Test
Job Set-Up Information
Manpower/Resources/Skills
Man-hours 0.25 h
Minimum Number of person 1
Elapsed Time 0.25 h
Referenced Information
Manuals/Drawings References/Sheets
AMM Task 24-41-00-861-002
Manuals/Drawings References/Sheets
Task 24-41-00-862-002
24-50-00, Page Block 001
Task 31-32-00-860-010
Task 34-43-34-400-004
Procedure
(a) Do the test procedure as specified after the installation of the T2CAS Computer
(FIN 100SG), refer to Ref. AMM Task 34-43-34-400-004.
(b) Do the LRU identification test:
1 Job Set-up:
a Energize the aircraft electrical circuits, refer to Ref. AMM Task 24-41-
00-861-002.
b Do the procedure to get access to the SYSTEM REPORT/TEST NAV
page on the Multipurpose Control Display Unit (MCDU), refer to Ref.
AMM Task 31-32-00-860-010:
- push the NEXT PAGE function key (two times) until the TCAS
indication comes into view.
c Make sure that these circuit breakers are closed:
NOTE: For the circuit breaker location, refer to Ref. AMM 24-50-00,
Page Block 001.
2 Procedure:
NOTE: The actions and the results of this procedure occur on the MCDU
used.
ACTION RESULT
1. On the MCDU: On the MCDU:
- Push the line key adjacent to the TCAS - The TCAS page comes into view.
indication.
- The LRU INDENTIFICATION pages
- Push the line key adjacent to the LRU comes into view.
IDENT indication.
2. On the TCAS LRU IDENTIFICATION page:
<1> On the MCDU, push the line key adjacent to the RETURN
indication until the CFDS menu page comes into view.
b De-energize the aircraft electrical circuits, refer to Ref. AMM Task 24-
41-00-862-002.
F. CLOSE-UP
(1) Task A320-A-34-XX-1539-01001-740A-A (A320-A-34-XX-1539-01ZZZ-740Z-A)
Close-up
Job Set-Up Information
Manpower/Resources/Skills
Man-hours 0.50 h
Minimum Number of person 1
Elapsed Time 0.50 h
Referenced Information
Manuals/Drawings References/Sheets
Task 34-43-34-400-004
AMM
Task 52-10-00-410-001
Procedure
(a) Make sure that the work areas are clean and clear of tools and other items of
equipment.
(b) Do the Close-up procedure as specified in the installation of the Traffic and
Terrain Alert and Collision Avoidance System (T2CAS) Computer (FIN 100SG),
refer to Ref. AMM Task 34-43-34-400-004.
(c) Close the FWD passenger/crew door Door 831, refer to Ref. AMM Task 52-10-00-
410-001.
(d) Put the aircraft back to its initial configuration.
G. ADMINISTRATIVE
(1) Task A320-A-34-XX-1539-01001-90AA-A (A320-A-34-XX-1539-01ZZZ-90AZ-A)
Administrative
Procedure
(a) Confirm in the applicable aircraft records that you have completed all the work
defined in this Service Bulletin task set as required.
WARNING: MAKE SURE THAT YOU OBEY ALL THE WARNINGS AND ALL THE CAUTIONS
INCLUDED IN THE REFERENCED PROCEDURES.
NOTE: The accomplishment instructions of this Service Bulletin include procedures given in
other documents or in other sections of the Service Bulletin. When the words “refer to”
are used and the operator has a procedure accepted by the local authority he belongs to,
the accepted alternative procedure can be used. When the words “in accordance with”
are used then the given procedure must be followed.
NOTE: The access and close-up instructions, not comprising return to service tests, in this
Service Bulletin do not constitute or affect the technical intent of the Service Bulletin.
Operators can therefore, as deemed necessary, omit or add access and/or close-up steps
to add flexibility to their maintenance operations as long as the technical intent of the
Service Bulletin is met within the set parameters.
NOTE: Manual titles given in the accomplishment instructions are referred to by acronyms. Refer
to paragraph 1.J., References, for the definition of acronyms.
NOTE: This Service Bulletin contains the instructions for the on-aircraft maintenance necessary
to ensure the continued airworthiness of the aircraft.
For any deviations to the instructions, contact AIRBUS for further instructions and
approval.
Man-hours 0.50 h
Minimum Number of person 1
Referenced Information
Manuals/Drawings References/Sheets
Task 12-34-24-869-002
AMM Task 34-43-34-000-004
Task 52-10-00-010-001
Procedure
NOTE: For the basic Aircraft configuration, refer to AMM Chapter “Introduction -
Aircraft status for maintenance" in Manual Front Matter section.
(a) Make sure that the aircraft is electrically grounded, refer to Ref. AMM Task 12-34-
24-869-002.
(b) Put the access platform(s) in position.
(c) Open the FWD passenger/crew door Door 831, refer to Ref. AMM Task 52-10-00-
010-001.
(d) Do the preparation procedure as specified in the removal of the Traffic and
Terrain Alert and Collision Avoidance System (T2CAS) Computer (FIN 100SG),
refer to Ref. AMM Task 34-43-34-000-004.
C. PROCEDURE
(1) Task A320-A-34-XX-1539-02001-920A-A (A320-A-34-XX-1539-02ZZZ-920Z-A)
In the AFT Electronics Rack 80VU, Upload the Traffic and Terrain Alert and
Collision Avoidance System (T2CAS) Computer (100SG)
Job Set-Up Information
Working Area
Manuals/Drawings References/Sheets
Task 20-16-00-912-001
Task 24-41-00-861-002
AMM 24-50-00, Page Block 001
Task 31-32-00-860-010
Task 34-43-00-740-004
VSB ACSS (1WYD3) VSB 9000000-34-6026
Procedure
(a) Standard Practices
1 For circuit breaker safety precautions, refer to Ref. AMM Task 20-16-00-912-
001.
(b) Do the Built-In Test Equipment (BITE) Test of the Traffic and Terrain Alert and
Collision Avoidance System (T2CAS) Computer (FIN 100SG), refer to Ref. AMM
Task 34-43-00-740-004.
(c) Do the LRU identification test:
1 Job Set-up:
a Energize the aircraft electrical circuits, refer to Ref. AMM Task 24-41-
00-861-002.
b Do the procedure to get access to the SYSTEM REPORT/TEST NAV
page on the MCDU, refer to Ref. AMM Task 31-32-00-860-010.
- Push the NEXT PAGE function key (two times) until the TCAS
indication comes into view.
c Make sure that these circuit breakers are closed:
NOTE: For the circuit breaker location, refer to Ref. AMM 24-50-00,
Page Block 001.
2 Procedure:
NOTE: The actions and the results of this procedure occur on the MCDU
used.
ACTION RESULT
1. On the MCDU: On the MCDU:
- Push the line key adjacent to the TCAS - The TCAS page comes into view.
indication.
- The LRU IDENTIFICATION page comes
- Push the line key adjacent to the LRU into view.
indication.
2. On the TCAS LRU IDENTIFICATION page:
NOTE: For the circuit breaker location, refer to Ref. AMM 24-50-00, Page Block
001.
(e) Make sure that the aircraft is in ground configuration (Landing gear down and
compressed).
(f) Make sure that these circuit breakers are closed:
NOTE: For the circuit breaker location, refer to Ref. AMM 24-50-00, Page Block
001.
(g) Do the uploading of the T2CAS Computer (FIN 100SG) in accordance with Ref.
ACSS (1WYD3) VSB 9000000-34-6026.
During the accomplishment of Ref. ACSS (1WYD3) VSB 9000000-34-6026, it is
necessary to remove or to apply electrical power to the T2CAS Computer as
described in the following notes:
NOTE: To remove the electrical power from the T2CAS Computer, open, safety/
lock and tag the following circuit breaker:
NOTE: For the circuit breaker location, refer to Ref. AMM 24-50-00, Page Block
001.
NOTE: To apply the electrical power to the T2CAS Computer, remove the safety
clip and/or tag and close/unlock the following circuit breaker:
NOTE: For the circuit breaker location, refer to Ref. AMM 24-50-00, Page Block
001.
FIN 100SG
1 COMPUTER-T2CAS 9000000-11313
Becomes
FIN 100SG
1 COMPUTER-T2CAS 9000000-11414
D. PREPARATION FOR TEST
None
E. TEST
(1) Task A320-A-34-XX-1539-02001-390A-A (A320-A-34-XX-1539-02ZZZ-390Z-A)
Test
Man-hours 0.50 h
Minimum Number of person 1
Elapsed Time 0.50 h
Referenced Information
Manuals/Drawings References/Sheets
Task 24-41-00-862-002
24-50-00, Page Block 001
AMM
Task 31-32-00-860-010
Task 34-43-00-740-004
Procedure
(a) Procedure:
1 Do the BITE test of the Traffic and Terrain Alert and Collision Avoidance
System (T2CAS) Computer (FIN 100SG), refer to Ref. AMM Task 34-43-00-
740-004.
2 Do the LRU identification test:
a Job Set-up:
<1> Do the procedure to get access to the SYSTEM REPORT/TEST
NAV page on the MCDU, refer to Ref. AMM Task 31-32-00-860-
010:
- Push the NEXT PAGE function key (two times) until the
TCAS indication comes into view.
<2> Make sure that these circuit breakers are closed:
NOTE: For the circuit breaker location, refer to Ref. AMM 24-
50-00, Page Block 001.
b Procedure:
NOTE: The actions and the results of this procedure occur on the
MCDU used.
ACTION RESULT
1. On the MCDU: On the MCDU:
- Push the line key adjacent to the TCAS - The TCAS page comes into view.
indication.
- The LRU INDENTIFICATION pages
- Push the line key adjacent to the LRU comes into view.
IDENT indication.
2. On the TCAS LRU IDENTIFICATION page:
ACTION RESULT
- Check the new PN of the TCAS (PN
9000000-11414)
3. Print the TCAS LRU IDENTIFICATION page
(if the printer is not available, a visual check
is acceptable).
c Close-up
<1> Put the aircraft back to its initial configuration.
<a> On the MCDU, push the line key adjacent to the RETURN
indication until the CFDS menu page comes into view.
<b> De-energize the aircraft electrical circuits, refer to Ref.
AMM Task 24-41-00-862-002.
F. CLOSE-UP
(1) Task A320-A-34-XX-1539-02001-740A-A (A320-A-34-XX-1539-02ZZZ-740Z-A)
Close-up
Job Set-Up Information
Manpower/Resources/Skills
Man-hours 0.50 h
Minimum Number of person 1
Elapsed Time 0.50 h
Referenced Information
Manuals/Drawings References/Sheets
Task 34-43-34-400-004
AMM
Task 52-10-00-410-001
Procedure
(a) Make sure that the work areas are clean and clear of tools and other items of
equipment.
(b) Do the close-up procedure as specified in the installation of the Traffic and
Terrain Alert and Collision Avoidance System (T2CAS) Computer (FIN 100SG),
refer to Ref. AMM Task 34-43-34-400-004.
(c) Close the FWD passenger/crew door Door 831, refer to Ref. AMM Task 52-10-00-
410-001.
(d) Remove the access platform(s).
(e) Put the aircraft back to its initial configuration.
G. ADMINISTRATIVE
(1) Task A320-A-34-XX-1539-02001-90AA-A (A320-A-34-XX-1539-02ZZZ-90AZ-A)
Administrative
Procedure
(a) Confirm in the applicable aircraft records that you have completed all the work
defined in this Service Bulletin task set as required.
WARNING: MAKE SURE THAT YOU OBEY ALL THE WARNINGS AND ALL THE CAUTIONS
INCLUDED IN THE REFERENCED PROCEDURES.
NOTE: The accomplishment instructions of this Service Bulletin include procedures given in
other documents or in other sections of the Service Bulletin. When the words “refer to”
are used and the operator has a procedure accepted by the local authority he belongs to,
the accepted alternative procedure can be used. When the words “in accordance with”
are used then the given procedure must be followed.
NOTE: The access and close-up instructions, not comprising return to service tests, in this
Service Bulletin do not constitute or affect the technical intent of the Service Bulletin.
Operators can therefore, as deemed necessary, omit or add access and/or close-up steps
to add flexibility to their maintenance operations as long as the technical intent of the
Service Bulletin is met within the set parameters.
NOTE: Manual titles given in the accomplishment instructions are referred to by acronyms. Refer
to paragraph 1.J., References, for the definition of acronyms.
NOTE: This Service Bulletin contains the instructions for the on-aircraft maintenance necessary
to ensure the continued airworthiness of the aircraft.
For any deviations to the instructions, contact AIRBUS for further instructions and
approval.
Man-hours 0.50 h
Minimum Number of person 1
Elapsed Time 0.50 h
Referenced Information
Manuals/Drawings References/Sheets
Task 12-34-24-869-002
AMM Task 34-43-34-000-004
Task 52-10-00-010-001
Procedure
NOTE: For the basic Aircraft configuration, refer to AMM Chapter “Introduction -
Aircraft status for maintenance" in Manual Front Matter section.
(a) Make sure that the aircraft is electrically grounded, refer to Ref. AMM Task 12-34-
24-869-002.
(b) Put the access platform(s) in position.
(c) open the FWD passenger/crew door Door 831, refer to Ref. AMM Task 52-10-00-
010-001.
(d) Do the Job Set-up procedure as specified in the removal of the Traffic and Terrain
Alert and Collision Avoidance System (T2CAS) Computer (FIN 100SG), refer to
Ref. AMM Task 34-43-34-000-004.
C. PROCEDURE
(1) Task A320-A-34-XX-1539-03001-920A-A (A320-A-34-XX-1539-03ZZZ-920Z-A)
In the AFT Electronics Rack 80VU, Replace the Traffic and Terrain Alert and
Collision Avoidance System (T2CAS) Computer (100SG)
Job Set-Up Information
Working Area
Man-hours 1.00 h
Minimum Number of person 1
Elapsed Time 1.00 h
Material necessary to do the job
Equipment
ITEM PART No. QTY (UM) KEYWORD DRAWING SEE NOTES
9000000-11414 1 COMPUTER (1)
NOTE(S)
(1): The components listed above are not an AIRBUS Kit, the required parts must be
ordered as necessary through the given channel.
Referenced Information
Manuals/Drawings References/Sheets
Task 20-16-00-912-001
AMM Task 34-43-34-000-004
Task 34-43-34-400-004
Procedure
(a) Standard Practices
1 For circuit breaker safety precautions, refer to Ref. AMM Task 20-16-00-912-
001.
(b) In the AFT Electronics Rack Electrical Panel 80VU, replace the T2CAS Computer
(FIN 100SG)
1 Remove:
Refer to Ref. AMM Task 34-43-34-000-004
FIN 100SG
1 COMPUTER-T2CAS 9000000-11313 Discard
2 Install:
Refer to Ref. AMM Task 34-43-34-400-004
FIN 100SG
1 COMPUTER-T2CAS 9000000-11414
D. PREPARATION FOR TEST
(1) Task A320-A-34-XX-1539-02001-92AA-A (A320-A-34-XX-1539-02ZZZ-92AZ-A)
Test Job Set-up
Job Set-Up Information
Manpower/Resources/Skills
Man-hours 0.25 h
Minimum Number of person 1
Elapsed Time 0.25 h
Referenced Information
Manuals/Drawings References/Sheets
Task 24-41-00-861-002
AMM
Task 34-43-34-400-004
Procedure
(a) Remove the safety clips and/or tags and close/unlock the circuit breakers as
specified after the installation of Traffic and Terrain Alert and Collision Avoidance
System (T2CAS) Computer (FIN 100SG), refer to Ref. AMM Task 34-43-34-400-
004.
(b) Energize the aircraft electrical circuits, refer to Ref. AMM Task 24-41-00-861-002.
E. TEST
(1) Task A320-A-34-XX-1539-03001-390A-A (A320-A-34-XX-1539-03ZZZ-390Z-A)
Procedure
Job Set-Up Information
Manpower/Resources/Skills
Man-hours 0.25 h
Minimum Number of person 1
Elapsed Time 0.25 h
Referenced Information
Manuals/Drawings References/Sheets
Task 24-41-00-862-002
24-50-00, Page Block 001
AMM
Task 31-32-00-860-010
Task 34-43-34-400-004
Procedure
(a) Do the test procedure as specified after the installation of the Traffic and Terrain
Alert and Collision Avoidance System (T2CAS) Computer (FIN 100SG), refer to
Ref. AMM Task 34-43-34-400-004.
(b) Do the LRU identification test
(c)
1 Job Set-up:
a Do the procedure to get access to the SYSTEM REPORT/TEST NAV
page on the MCDU, refer to Ref. AMM Task 31-32-00-860-010:
- Push the NEXT PAGE function key (two times) until the TCAS
menu page comes into view.
b Make sure that these circuit breakers are closed:
NOTE: For the circuit breaker location, refer to Ref. AMM 24-50-00,
Page Block 001.
2 Procedure:
NOTE: The actions and the results of this procedure occur on the MCDU
used.
ACTION RESULT
1. On the MCDU: On the MCDU:
- Push the line key adjacent to the TCAS - The TCAS page comes into view.
indication.
- The LRU INDENTIFICATION pages
- Push the line key adjacent to the LRU comes into view.
IDENT indication.
2. On the TCAS LRU IDENTIFICATION page:
4 De-energize the aircraft electrical circuits, refer to Ref. AMM Task 24-41-00-
862-002.
F. CLOSE-UP
(1) Task A320-A-34-XX-1539-03001-740A-A (A320-A-34-XX-1539-03ZZZ-740Z-A)
Close-up
Job Set-Up Information
Manpower/Resources/Skills
Man-hours 0.50 h
Minimum Number of person 1
Elapsed Time 0.50 h
Referenced Information
Manuals/Drawings References/Sheets
Task 34-43-34-400-004
AMM
Task 52-10-00-410-001
Procedure
(a) Make sure that the work areas are clean and clear of tools and other items of
equipment.
(b) Do the close-up procedure as specified in the installation of the Traffic and
Terrain Alert and Collision Avoidance System (T2CAS) Computer (FIN 100SG),
refer to Ref. AMM Task 34-43-34-400-004.
(c) Close the FWD passenger/crew door 831, refer to Ref. AMM Task 52-10-00-410-
001.
(d) Put the aircraft back to its initial configuration.
G. ADMINISTRATIVE
(1) Task A320-A-34-XX-1539-03001-90AA-A (A320-A-34-XX-1539-03ZZZ-90AZ-A)
Administrative
Procedure
(a) Confirm in the applicable aircraft records that you have completed all the work
defined in this Service Bulletin task set as required.
NOTE: ISI 00.00.00179 covers all the frequently asked questions about SB Reporting.
It is revised on a regular basis.
If you have difficulties in the accomplishment of this SB please quote below the area(s) and
give a short description of the issue.
Comments :
Operator : Date :
Name/Title
Please return this form to :
AIRBUS
2, ROND POINT EMILE DEWOITINE
31700 BLAGNAC
FRANCE
Or via your Resident Customer Support Office.