You are on page 1of 2

True or False

1.A router is a network device used to regenerate or replicate a signal as it weakens when travelling on a
network.

Answer: False

2.A bridge is used to connect two different LANs or two segments of the same LAN by forwarding
network traffic between network segments.

Answer: True

3.The highest capacity wireless media is satellite microware.

Answer: False

4.The standard protocol of the Internet is Ethernet.

Answer: False

5.A hub connects two different LANs.

Answer: False

6.Circuit switched networks run over the public switched telephone networks operated by the common
carriers.

Answer: True

7.Full mesh networks are inexpensive.

Answer: False

8.Wireless LANs use Carrier Sense Multiple Access with Collision Detection (CSMA/CD) for medic access
control.

Answer: False

9.Wireless LANs are never connected to a wire network.

Answer: False

10.An access point (AP) is required to connect a WLAN to a wired network.

Answer: True

11.Routers use network layer address to forward packets between network segments.

Answer: True

12.One of the least common uses of gateways is to enable LANs that use TCP/IP and Ethernet to
communicate with mainframes that use other protocols.

Answer: False
13.The most common standard for dynamic addressing for TCP/IP networks is Dynamic Host Control
Protocol.

Answer: True

14.LANs can be categorized as either dedicated (with a dedicated server) or peer-to-peer (without a
dedicated server).

Answer: True

15.One of the most important functions of Network Operating System (NOS) is a directory service.

Answer: True

16.The Ethernet standard was developed first by the IEEE.

Answer: False

17.The network layer is responsible for end-to-end delivery of the message.

Answer: False

18.IPv4 addresses offer unlimited opportunity for expansion and growth on the Internet.

Answer: False

19.Polling is the process of permitting all clients to transmit or receive at any time.

Answer: False

20.UTP is the cheapest cabling choice

Answer: True

21.An advantage of a Star Topology is that it is easy to install and wire.

Answer: True

22.Data on a star network passes through the hub, switch, or concentrator before continuing to its
destination.

Answer: True

23.In local area networks where bus topology is used, each machine is connected to a single cable.

Answer: True

24.Bus topology uses token passing.

Answer: False

25.Ip version 4 are 64 bits.

Answer: False

You might also like