Professional Documents
Culture Documents
1. Determine the IP addresses that are useable for hosts on the subnetworks of the 200.100.50.0/28
network.
3. Which function is a unique responsibility of the DCE devices shown in the exhibit?
a. transmission of data
b. reception of data
4. A router which terminates a serial WAN link is typically a DTE device. Under which circumstance
would a router be configured as a DCE device?
a. A router cannot be configured as a DCE device.
d. When the clock rate from the service provider cannot be matched by the router.
a. 10.1.1.1
b. 172.32.5.2
c. 192.167.10.10
d. 172.16.4.4
e. 192.168.5.5
f. 224.6.6.6
6. Match the “slash format” number with the mask number to subnet the last octet.
7. Refer to the exhibit. What type of cable connects the two routers together without any intermediary
device?
a. console
b. rollover
c. crossover
d. straight-through
8. Refer to the exhibit. Which option defines the default port configuration settings used to establish the
direct serial connection between a computer and Cisco networking device?
a. 19, 200 bps, 8 data bits, no parity, 1 stop bit, no flow control
b. 9600 bps, 8 data bits, even parity, 2 stop bits, hardware flow control
c. 9600 bps, 16 data bits, odd parity, 1 stop bit, hardware flow control
d. 19, 200 bps, 8 data bits, even parity, 1 stop bit, hardware flow control
9. Which UTP cable lengths are specified by ANSI/TIA/EIA-568-B standards? (Choose three.)
1. Which addresses are valid host IP addresses, given the subnet mask 255.255.255.248?
(Choose three.)
A. 192.168.200.87
B. 194.10.10.104
C. 223.168.210.100
D. 220.100.100.154
E. 200.152.2.160
F. 196.123.142.190
2. Host A in Figure 1is assigned the IP address 10.118.197.55/20. How many more
A. 253
B. 509
C. 1021
D. 2045
E. 4093
3. The devices in Figure 2 have been configured with a static IP address from the network
192.168.102.0. All hosts can communicate with each other but cannot communicate
with the server. What is causing this problem?
D. The switch that the server is connected to has not been assigned an IP address.
192.168.102.64 network.
4. A contractor is installing cable for a new hospital network. The cable specifications
require that the network be protected from EMI and have a supported bandwidth of
E. Fiber-optic cable
5. Which two items are required for initial configuration of Cisco routers?
A. Crossover cable
B. Rollover cable
C. RJ-15–to–DB-9 adapter
6. List four types of interfaces found on Cisco routers and switches, and give the function
of each.