Professional Documents
Culture Documents
by Utsource123
Hii friend,
Today I am going to make a circuit of Volume, bass and treble.This circuit will control the volume of amplifier and
bass and it will also control the treble of the amplifier.This circuit will be only for single channel audio amplifier.This
circuit I will use in 6283 IC single channel audio amplifier board.As we learnt the wiring of 6283 ic amplifier board
in previous blog.
Components required -
Firstly we have to connect wires in 1st pin of potentiometer-1 to 1st pin of potentiometer-2 (This wire is connected
in potentiometer for audio input)
Next connect 3rd pin of potentiometer-1 to 3rd pin of potentiometer-2 (This wire is for ground).
Next we have to connect 0.01uf ceramic capacitor (103pf) to pin-1 and pin-2 of potentiometer-1 which is for Bass
as you can see in the picture.
Next we have to connect 4.7K resistor to the middle pin of Bass potentiometer as you can see in the picture.
Now we have to connect 100nf (104pf) Ceramic capacitor in series to the middle pin of treble potentiometer as
shown in the picture.
Next connect wires in the output of 4.7K resistor and in 100nf (104pf) capacitor as you can see in the picture.
Bass and treble circuit is ready so now we have to connect volume potentiometer.
Connect wire in the 2nd pin of Volume potentiometer to pin-1 of Bass potentiometer and
Connect aux cable Left/Right wire in pin-1 of volume potentiometer and ground wire in 3rd pin of volume
potentiometer as picture.
Next connect a wire in the GND pin of potentiometer which is 3rd pin of all potentiometer.
Connect output wires of 4.7K resistor and 104 pf to input pin of Amplifier board and GND wire to the Ground pin of
amplifier as you can see in the picture.
Now Volume , Bass and Treble circuit is ready so let's check it.
Give power supply to the amplifier board and plug in aux cable to mobile phone and play songs.
Rotate the knob of bass and treble potentiometer and enjoy songs with bass and treble sound.
Thank you