Professional Documents
Culture Documents
A. B31.1
B. B31.3
C. B31.4
D. B31.8
16. Heating of a portion to a sufficient temp below the transformation temp range to relieve the
major portion of the residual stresses, followed by uniform cooling slowly to minimize the
development of new residual stresses?
a. Stress relief
b. PWHT
c. Tempering
d. None
17. As per B31.3 hardened material has been heated to increase the toughness?
a. Quenching
b. Tempering
c. Normalizing
d. Annealing
18. Which statement is not true for the performance qualification by ASME B31.3?
a. Welder and welding operator shall be used only for specific pipe and tubes
b. The employer shall have the WPS that was followed during qualification
c. The record shall show the name of the employer, the welder with date of the qualification
19. What P&ID
A) Piping and Instrumentation Diagram
B) Piping and Instrumentation Drawing
C) Both A & B
D) None of the above
20. Who is responsible for delivering the material, components and workmanship as per ASME
B31.3 Boiler and Pressure Vessel Design Code
A) Owner
B) manufacturer
C) Fabricator
D) Manufacturer, Fabricator, Erector
21. What are the International standards for pipe
a. API5L
b. ASTM A 106
c. ASTM 333
d. All the above
23. Pipe having a helical seam with either butt, lap or lock seam joint.
ERW
ESW
Spiral weld
Fusion weld
24. Standard for Surface Finish
A) MSS SP-25
B) MSS SP-6
C) MSS SP-51
D) NONE OF THE ABOVE
25. Impact testing is not required above which Design temperature for CS
A. -104C/-155F
B. -29C/-20F
C. -48C/-55F
D. NONE OF THE ABOVE
26. Consumable insert – definition
27. Tie in temperature measure at
Existing to new pipeline
Placed valve between
Pipeline String to string or to anchor
28. Pipe ratio of connecting branch tee as per ASME B 16.25
A)+-3mm
B)+-10mm
C)+-3 MM
D) None of the above