You are on page 1of 3

US03CHPHY22

UNIT – 4
1 FET is a _____________ device.
a) Resistance b) Voltage c) Current d) power
controlled controlled controlled
2 The input resistance of FET is _________.
a) zero b) negative c) in the order of d)in the order of
KΩ mega Ω
3 The ohmic resistance of the FET is ___________.

a) Few hundred b) zero c) few KΩ d) few MΩ


Ω
4 JFET is often called___________device.
a) Transconductance b)Transresistance c) Square law d) High gain
5 What is the drain saturation current of a gate biased FET for VDD = 10V, RD= 10KΩ VP= 4V
and IDSS= 10mA?
a) 1mA b) 10mA c) 0.4mA d) 4mA
6 The current source bias circuit has VDD = 10V, RD = 1KΩ,RE= 2KΩ and RG= 1MΩ. What is
the drain voltage?
a) 10V b) 7.85V c) 8.85V d) 6.85V
7 What is the unit of transconductance?
a) Volt/Amp b) ampere c) ohm e) Amp/volt
8 What is the value of gm of JFET whose VGS(off) = -2V, VGS = 1V and gmo = 2nsiemen
a) 2500siemen b) 2500 milli siemen c) 2500microsiemen d) 2500 neno siemen
9 The voltage gain of the common source amplifier is A =_______.
a) gmrd b) gmrd /(1 + gmrd) c) vd/ gmrd d) id/ gmrd
10 To use JFET as analog switch the JFET is operates in which region?
a) Active or cutoff b) ohmic or c) saturation or d) active or ohmic
cutoff cutoff
11 What is the value of RD of JFET analog shunt switch?
a) < RDS b) = RDS c) = 0 d) > RDS
12 The circuit which converts DC voltage to a square wave is called______.
a) Amplifier b) Switch c) chopper d) multiplexer
13 What is the on – off ratio of the JFET switch for vout = 9.8mV and vout= 10μV ?
a) 980 b) 9.8 c) 0.98 d) 98
14 What is the meaning of multiplexer?
a) One input Multi b) Many input one c) Many input many d) One input one out
output output putput put
15 Chopper amplifiers are used for ______.
a) DC amplifier b) Ac amplifier c) Voltage amplifier d) Current amplifier
16 The minimum VGS that creates the n – type inversion layer is called______ voltage.
a) Saturation b) Cut off c) threshold d) Pinch off
17 With ______ gate voltage JFET is on and E – MOSFET is off
a) positive b) zero c) negative d) non of above
18 The power consumption of the CMOS at quiescent is________.
a) increases b) fluctuate c) decreases d) approaches
zero

SHORT QUESTIONS:
1. Draw the schematic symbols of N-channel JFET, D-MOSFET and
E-MOSFET.
2. Explain hard saturation.
3. Explain current source bias.
4. Draw the ac equivalent circuit of CS amplifier.
5. Draw the block diagram of a chopper amplifier.
6. Explain working of a multiplexer with necessary circuit.
LONG QUESTIONS:
1. In brief explain drain characteristics of n channel JFET.
2. Explain various biasing circuits to bias n channel JFET in active region.
3. In brief explain analog switch.
4. Explain working of Automatic gain control.
5. In brief explain enhancement -mode MOSFET.
6. Write a notes on digital switches using E- MOSFET.
7. Explain CMOS.

You might also like