Professional Documents
Culture Documents
Guide
1. Setup port
mikroBootloader manual
2. Connect with MCU
mikroBootloader manual
UART bootloader for PIC16 and PIC18 MCUs
appropriate device firmware, which is free of charge and can appropriate COM Connect button
be downloaded from mikroElektronika’s website. port in the Setup within 5s. The chip
2
window. Set Baud automatically enters
If your board utilizes UART communication over the FTDI
Rate value to match the Bootloader
chip, it is necessary to install the appropriate driver for the
your configuration in mode and is
operating system you use. Drivers may be downloaded at:
MCU firmware. ready for further
Click OK to proceed. instructions.
http://www.ftdichip.com/Drivers/VCP.htm
your HEX on to
Opened: C:\Users\mmatovic.MIK\Desktop\
yy: 12
mikroBootloader final\led.hex
xx: 148
mikroBootloader xx: 0
yy: 0
window. You’ll
yy: 12
that the file is Start bootloader by clicking on the Begin uploading button.
opened.
File: C:\Users\mmatovic.MIK\Desktop\mikroBootloader final\led.hex
The whole process is performed in two phases. Click on the
Show Activity button to view the operation of the bootloader.