Professional Documents
Culture Documents
DC TO DC CONVERTER
CONTROLLER
DESCRIPTION
The Contek MC34063 is a monolithic regulator
subsystem, intended for use as DC to DC converter.
This device contains a temperature compensated band SOP-8
gap reference, a duty-cycle control oscillator, driver
and high current output switch. It can be used for step
down, step-up or inverting switching regulators as well
as for series pass regulators.
FEATURES
*Operation from 3.0V to 40V.
*Short circuit current limiting. DIP-8
*Low standby current.
*Output switch current of 1.5A without external
transistors.
*Frequency of operation from 100Hz to 100kHz.
*Step-up, step-down or inverting switch regulators.
PIN CONFIGURATION
Switch Driver
Collector 1 8 Collector
Switch
Emitter 2 Contek 7 Lpk Sense
MC34063
Timing
3 6 Vcc
Capacitor
Comparator
Gnd 4 5 Inverting input
BLOCK DIAGRAM
E
SWITCH T2 S
DRIVE
COLLECTOR 1 Q 8 COLLECTOR
R
T1 D
SWITCH C Ipeak
EMITTER
2 7 SENSE
Is
A
CT
TIMING OSCILLATOR
CAPACITOR
3 6 Vcc
COMP.
GND 4 1.25Vref 5 COMPARATOR
B INVERTING
INPUT
Contek
NOTE: Output switch tests are performed under pulsed conditions to minimize power dissipation.
http://www.contek-ic.com E-mail:sales@contek-ic.com
CONTEK
MC34063 LINEAR INTEGRATED CIRCUIT
Contek
Contek Contek
http://www.contek-ic.com E-mail:sales@contek-ic.com
CONTEK
MC34063 LINEAR INTEGRATED CIRCUIT
Contek
Contek Contek
http://www.contek-ic.com E-mail:sales@contek-ic.com
CONTEK
MC34063 LINEAR INTEGRATED CIRCUIT
Contek
Contek
Contek
http://www.contek-ic.com E-mail:sales@contek-ic.com
CONTEK
This datasheet has been downloaded from:
www.DatasheetCatalog.com