Professional Documents
Culture Documents
Parameter:
1. Power supply voltage: 12V
2. Maximum working current: 2A
3. Optical output power (MAX): 5.5W
4. Laser wavelength: 455nm
5. Focal length: 20mm
6. Laser head size: 33*33*99mm
7. Laser drive size: 40*67*25mm
PWM PWM
GND GND 2 5
12V
1
3 6
1
Install the Laser Module
1.4 Install the module and fix the focus positioning column.
1.4.1 We recommend that you use the offline controller to drive the Z-axis motor, lower the spindle clamp
to the lowest position, which touched Z LIM-switch.
1.4.2 Loosen the M4 screw (Red Frame) and insert the Module.
3
1.4.3 We use the focus positioning column, the height is 20mm, and 20mm length of the laser
head refers to the distance between the end face of the radiator and the engraving material.
According to the thickness of different materials, the distance between the laser head and
the material needs to be adjusted so that the distance between the radiator and the material
is always 20mm, AS shown in the figure below.
4
20mm
Material
Workbench