Professional Documents
Culture Documents
Basophor® ELH 60
Revision date : 2007/02/06 Page: 1/6
Version: 2.0 (30241057/MDS_GEN_US/EN)
2. Composition/information on ingredients
CAS Number Content (W/W) Chemical name
61788-85-0 castor oil, hydrogenated, ethoxylated
3. Hazard identification
Emergency overview
4. First-aid measures
General advice:
Remove contaminated clothing.
If inhaled:
Remove the affected individual into fresh air and keep the person calm. Seek medical attention.
Safety data sheet
Basophor® ELH 60
Revision date : 2007/02/06 Page: 2/6
Version: 2.0 (30241057/MDS_GEN_US/EN)
If on skin:
Wash thoroughly with soap and water.
If in eyes:
Wash affected eyes for at least 15 minutes under running water with eyelids held open.
If swallowed:
Rinse mouth and then drink plenty of water. Do not induce vomiting. Immediate medical attention required.
Note to physician
Treatment: Treat according to symptoms (decontamination, vital functions), no known
specific antidote.
5. Fire-fighting measures
Flash point: > 100 °C
Autoignition: > 200 °C (DIN 51794)
Flammability: does not ignite
Further information:
The degree of risk is governed by the burning substance and the fire conditions. Contaminated extinguishing
water must be disposed of in accordance with official regulations.
Environmental precautions:
Do not discharge into drains/surface waters/groundwater.
Cleanup:
Place absorbed material in the same container as the spilled substance/product for disposal.
For small amounts: Pick up with absorbent material (e.g. sand, sawdust, general-purpose binder). Dispose
of absorbed material in accordance with regulations.
For large amounts: Pump off product.
Further information:
High risk of slipping due to leakage/spillage of product.
Safety data sheet
Basophor® ELH 60
Revision date : 2007/02/06 Page: 3/6
Version: 2.0 (30241057/MDS_GEN_US/EN)
Storage
General advice:
Keep container tightly closed and dry; store in a cool place.
Temperature tolerance
Protect from temperatures below: 15 °C
The packed product is not damaged by low temperatures or by frost.
Protect from temperatures above: 70 °C
The packed product will be damaged by high temperatures.
Hand protection:
Chemical resistant protective gloves
Eye protection:
Tightly fitting safety goggles (chemical goggles).
Hazardous reactions:
No hazardous reactions when stored and handled according to instructions.
The product is chemically stable.
Decomposition products:
Safety data sheet
Basophor® ELH 60
Revision date : 2007/02/06 Page: 4/6
Version: 2.0 (30241057/MDS_GEN_US/EN)
Hazardous decomposition products: No hazardous decomposition products if stored and handled as
prescribed/indicated.
Oral:
LD50/rat: > 2,000 mg/kg
Skin irritation:
rabbit: non-irritant (BASF-Test)
Eye irritation :
rabbit: non-irritant (BASF-Test)
Chronic toxicity
Other information:
The product has not been tested. The statement has been derived from products of a similar structure and
composition.
Biodegradation:
Test method: OECD Guideline 302 B
Method of analysis: DOC reduction
Degree of elimination: 20 - 70 %
Environmental toxicity
Toxicity to microorganisms:
DIN 38412 Part 8 bacterium/EC10 (17 h): > 10,000 mg/l
Container disposal:
Dispose of in a licensed facility. Recommend crushing, puncturing or other means to prevent unauthorized
use of used containers.
Safety data sheet
Basophor® ELH 60
Revision date : 2007/02/06 Page: 5/6
Version: 2.0 (30241057/MDS_GEN_US/EN)
Land transport
USDOT
Not classified as a dangerous good under transport regulations
Sea transport
IMDG
Not classified as a dangerous good under transport regulations
Air transport
IATA/ICAO
Not classified as a dangerous good under transport regulations
Registration status:
TSCA, US released / listed
State regulations
CA Prop. 65:
THIS PRODUCT CONTAINS A CHEMICAL(S) KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER AND BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
HMIS uses a numbering scale ranging from 0 to 4 to indicate the degree of hazard. A value of zero means that the
substance possesses essentially no hazard; a rating of four indicates high hazard.