Professional Documents
Culture Documents
SUN-I Model M-100 - Installation and Use Instructions
SUN-I Model M-100 - Installation and Use Instructions
model M-100
Instructions for installing and using the M-100.
(New improved and improved M-10 system).
Specifications.
1. Compact receiver.
2. Two four-button self-learning ignition system protection transmitters (key fob).
3. Auto-inclusion (repeated).
4. Remote on-off.
5. Two turnip drives (installed on the machine).
6. Closing doors when the ignition is turned on.
7. Opening doors when the ignition is turned off.
8. Instant door latch.
9. Flashing signal lights (protected by a fuse) (can be connected to turn signals).
10. Disconnecting the starter
11. Search for a car.
12. Sound identification of the nature of the alarm (violation).
13. Memory when power off.
14. Can be connected to any alarm pager.
15. Disconnection of the starter and ignition system.
16. Electronic touch sensor for impact.
17. Various timer modes for closing doors (0.8 and 3.5 seconds).
18. Powerful siren.
19. After turning on the ignition, all functions except for opening / closing the doors are disabled.
20. Panic.
21. Door open alarm after ignition on.
Power up the alarm receiver by inserting a fuse or connecting the entire harness to the receiver. The alarm will turn on the siren. Turn the key in the ignition switch to the "ACC" position
and press the 1st button on one of the remote controls. The key fob will establish communication with the receiver. After that, the siren will sound 4 beeps, confirming that the
communication coding has been successfully set . If it doesn't, repeat the above procedure. After completing the coding, in order to start using the key fob, do not forget to turn the key in
the ignition lock.
After exiting the car, press the 1st button for 1/2 second. You will hear a long beep to confirm that the alarm has been activated.
With the ignition on, you can use the 1st and 2nd buttons to control the central locking, while other functions are not available for security reasons.
Siren duration:
When the touch sensor is triggered: 30 seconds with interruptions. Forcibly opening doors or starting ignition: 30 seconds continuously.
Automatic self-activation:
If you do not get into the car within 20 seconds after turning off the alarm, the alarm will automatically turn on and switch to security mode.
Disconnection:
Press the 2nd button. You will hear 2 beeps. The signal lights will come on three times. The door locks will open. The electricity will turn on.
This option was created for countries where loud sirens are prohibited in order not to disturb others when turned on. In silent mode, any violation that activates the alarm sends a signal to the
pager instead of triggering the siren. To use this function, we recommend connecting a pager to the alarm.
In case of any violation or its attempt, the siren will sound an audible signal that will let you know what happened.
If, when the alarm is turned on after the 1st beep, you hear 3 more short beeps - this means that the door has not slammed or that there is another malfunction. The alarm having activated
other protected zones will not arm the doors.
Panic.
Press and release the 4th button. The lights will blink 9 times. If you press the button again at this time, the siren will turn on. After 20 seconds, the machine will be de-energized. Press the
2nd button to stop this function.
For a vacuum central locking, the timer must be set to 3.5 seconds. To do this, cut off the black tie (loop).
Any attempt to turn off the power and then restore it will turn on the siren and lights. Then the power will be turned off by the alarm until the transmitter (key fob) is reprogrammed.
If any door remains open after turning on the ignition, the lamp will flash until the door is closed.
11/10/1999