Professional Documents
Culture Documents
Buzzers, Relays & Timers
Buzzers, Relays & Timers
TESTE
sexta-feira, 18 de Setembro de 2009 13:16:32
13:16:27 Page 1 © 2005 Mitchell Repair Information Company, LLC.
1993 BMW 325i
ELECTRICAL COMPONENT LOCATOR 1993 ELECTRICAL COMPONENT LOCATION BMW Electrical
Components
CONTROL UNITS
CONTROL UNITS LOCATION
Component Location
ABS Control Unit Under right side of dash, behind glove compartment. See
Fig. 3 .
Air Bag Module Under right side of dash, behind glove compartment. See
Fig. 3 .
Central Locking Module Under right side of dash, behind ABS control unit. See
Fig. 3 .
Check Control Module Under left side of dash. See Fig. 3 .
Crash Control Unit Behind left side of dash. See Fig. 2 .
Cruise Control Module Under right side of dash, behind glove compartment. See
Fig. 3 .
Digital Motor Electronics (DME) Control On right rear of engine compartment, behind battery
Unit console. See Fig. 4 .
EGS Control Unit (A/T) On right rear of engine compartment, behind battery
console. See Fig. 4 .
Headlight/Front Foglight Module Behind left side of dash. See Fig. 2 .
Integrated Climate Regulation Control Unit Under center of dash, forward of center console. See Fig.
3.
On-Board Computer Module Behind center console, forward of gear selector.
Sun Roof Computer Module Under roof center panel.
Windshield Wiper/Washer Module Behind left kick panel. See Fig. 4 .
MOTORS
MOTORS LOCATION
Component Location
Blower Motor Behind center console, in evaporator housing.
Gas Filler Door Lock Motor Behind right rear inner wheelwell.
Windshield Washer Pump In washer fluid reservoir.
Windshield Wiper Motor Near right side of steering column.
SWITCHES
SWITCHES LOCATION
Component Location
A/C Compressor Enable Switch Behind A/C control panel.
A/C Dual-Pressure Switch On top of receiver-drier, behind right headlight.
Back-Up Light Switch On top of transmission.
Brake Fluid Lever Switch In brake fluid reservoir cap.
Brake/Stoplight Switch On bracket, above brake pedal.
Coolant Level Switch In coolant reservoir.
Oil Pressure Switch On engine block, near oil dipstick.
TESTE
sexta-feira, 18 de Setembro de 2009 13:16:28 Page 3 © 2005 Mitchell Repair Information Company, LLC.
1993 BMW 325i
ELECTRICAL COMPONENT LOCATOR 1993 ELECTRICAL COMPONENT LOCATION BMW Electrical
Components
MISCELLANEOUS
MISCELLANEOUS LOCATION
Component Location
Blower Motor Resistor Behind center console, in evaporator housing.
Data Link Connector (20-Pin) On right rear of engine compartment.
DRL Coding Diode Below left side of dash.
NOTE: Figures may show multiple component locations. Refer to appropriate table
for proper figure references.
TESTE
sexta-feira, 18 de Setembro de 2009 13:16:28 Page 4 © 2005 Mitchell Repair Information Company, LLC.
1993 BMW 325i
ELECTRICAL COMPONENT LOCATOR 1993 ELECTRICAL COMPONENT LOCATION BMW Electrical
Components
TESTE
sexta-feira, 18 de Setembro de 2009 13:16:28 Page 5 © 2005 Mitchell Repair Information Company, LLC.
1993 BMW 325i
ELECTRICAL COMPONENT LOCATOR 1993 ELECTRICAL COMPONENT LOCATION BMW Electrical
Components
TESTE
sexta-feira, 18 de Setembro de 2009 13:16:28 Page 6 © 2005 Mitchell Repair Information Company, LLC.
1993 BMW 325i
ELECTRICAL COMPONENT LOCATOR 1993 ELECTRICAL COMPONENT LOCATION BMW Electrical
Components
TESTE
sexta-feira, 18 de Setembro de 2009 13:16:28 Page 7 © 2005 Mitchell Repair Information Company, LLC.