Professional Documents
Culture Documents
Lm2901 Amp Op Atx Dell
Lm2901 Amp Op Atx Dell
Features
■ Wide single supply voltage range or dual
supplies for all devices: +2 V to +36 V or ±1 V N
to ±18 V DIP14
■ Very low supply current (1.1 mA) independent (Plastic package)
of supply voltage (1.4 mW/comparator at +5 V)
■ Low input bias current: 25 nA typ.
■ Low input offset current: ±5 nA typ.
■ Input common-mode voltage range includes D
negative rail SO-14
■ Low output saturation voltage: (Plastic micropackage)
250 mV typ. (IO = 4 mA)
■ Differential input voltage range equal to the
supply voltage
■ TTL, DTL, ECL, MOS, CMOS compatible P
outputs TSSOP14
(Thin shrink small outline package)
Description
This device consists of four independent precision
voltage comparators, which are designed
specifically to operate from a single supply over a
wide range of voltages. Operation from split Q4
power supplies is also possible. QFN16 3x3
(Plastic micropackage)
These comparators also have a unique
characteristic in that the input common-mode
voltage range includes the negative rail even
though operated from a single power supply
voltage.
Output 2 1 14 O u tput 3
Output 1 2 13 O u tput 4
VCC+ 3 12 VC C -
Non-inverting
input
VO
Inverting
input
VCC
2 to 32
VCC Supply voltage V
±1 to ±16
Common mode input voltage range 0 to (VCC+ -1.5)
Vicm V
Tmin ≤ Tamb ≤ Tmax 0 to (VCC+ -2)
Toper Operating free-air temperature range -40 to +125 °C
3 Electrical characteristics
Figure 3. Supply current vs. supply voltage Figure 4. Input current vs. supply voltage
Figure 5. Output saturation voltage vs. Figure 6. Response time for various input
output current overdrives - negative transition
15 kΩ 100 kΩ
+V(ref)
+V(ref)
1/ 4 &
1/4 LM2901
LM2901 VO
-V(ref)
-V(ref)
15 kΩ
10 kΩ 1/4
LM2901
+V(ref) ~ el
1/ 4 & eo
LM2901
-V(ref)
100 kΩ 0.5 μF
& 1 kΩ
AV = 100
Figure 12. Low frequency op-amp with boost Figure 13. Transducer amplifier
5V 5V
(eo = 0 V for el = 0 V)
15 kΩ Magnetic pick-up 10 kΩ 3 kΩ
1/ 4
LM2901 2N 2222 1/ 4
~ el LM2901 eo
0.5 μF
20 MΩ
100 kΩ
eo
1 kΩ 10 kΩ
AV = 100
Figure 14. Low frequency op-amp with Figure 15. Zero crossing detector (single
offset adjust power supply)
5V
5V
1/ 4 1/ 4
el ~ LM2901 2N 2222 LM2901
1N4148
0.5 μ F
R1
100 kΩ
1 kΩ 20 MΩ
eo 10 kΩ
2RS 10 kΩ
V(ref)
high 1/ 4 5.1 kΩ
LM2901
Lamp
RS
1/4
LM2901
eo
eI ~
eI ~
1/ 4
LM139 2N 2222
2RS
V(ref)
low 15 V
Figure 18. Crystal controlled oscillator Figure 19. Comparator with a negative
reference
VCC = 15 V 15 V
200 kΩ 2 kΩ
100 kΩ
5.1 kΩ
VCC
1/ 4
0
0.1 μF LM2901 eo
1/ 4
LM2901
eo
eI ~
f = 100 kHz
200 kΩ 5V
15 V
VC C = +15 V
10 kΩ 15 kΩ 200 kΩ 3 kΩ
10 MΩ
10 kΩ
1/4 VCC
LM2901
V03
V3 to t3
3 kΩ
10 MΩ
10 kΩ 51 kΩ
VC1 10 kΩ
1/4
VCC LM2901
1/4
0
to tA LM2901 VO2 VCC
V2
V(ref.) to t2
Input gating signal 0.001 μF
3 kΩ
VCC
10 MΩ
51 kΩ
10 kΩ
1/4
V3 LM2901 V VCC
VC1 V2 O1
V1 t0 t1
V1
0 t
t 0 t1 t2 t3 t4 51 kΩ
100 kΩ
500 pF 3 kΩ 3 kΩ
1/ 4 5.1 kΩ
Frequency control
10 kΩ LM2901
voltage input 1/ 4
Vcontrol 0.01 μF LM2901 Output 1
0.1 μF
VCC /2
20 kΩ
Output 2
50 kΩ 20 kΩ
VCC /2
1/ 4
LM2901
VCC = + 30 V
+250 mV Vcontrol +50 V
700 Hz fo 100 kHz
5 Package information
Millimeters Inches
Ref.
Min. Typ. Max. Min. Typ. Max.
A 5.33 0.21
A1 0.38 0.015
A2 2.92 3.30 4.95 0.11 0.13 0.19
b 0.36 0.46 0.56 0.014 0.018 0.022
b2 1.14 1.52 1.78 0.04 0.06 0.07
c 0.20 0.25 0.36 0.007 0.009 0.01
D 18.67 19.05 19.69 0.73 0.75 0.77
E 7.62 7.87 8.26 0.30 0.31 0.32
E1 6.10 6.35 7.11 0.24 0.25 0.28
e 2.54 0.10
e1 15.24 0.60
eA 7.62 0.30
eB 10.92 0.43
L 2.92 3.30 3.81 0.11 0.13 0.15
Millimeters Inches
Ref.
Min. Typ. Max. Min. Typ. Max.
A 1.20 0.047
A1 0.05 0.15 0.002 0.004 0.006
A2 0.80 1.00 1.05 0.031 0.039 0.041
b 0.19 0.30 0.007 0.012
c 0.09 0.20 0.004 0.0089
D 4.90 5.00 5.10 0.193 0.197 0.201
E 6.20 6.40 6.60 0.244 0.252 0.260
E1 4.30 4.40 4.50 0.169 0.173 0.176
e 0.65 0.0256
L 0.45 0.60 0.75 0.018 0.024 0.030
L1 1.00 0.039
k 0° 8° 0° 8°
aaa 0.10 0.004
6 Ordering information
7 Revision history
Information in this document is provided solely in connection with ST products. STMicroelectronics NV and its subsidiaries (“ST”) reserve the
right to make changes, corrections, modifications or improvements, to this document, and the products and services described herein at any
time, without notice.
All ST products are sold pursuant to ST’s terms and conditions of sale.
Purchasers are solely responsible for the choice, selection and use of the ST products and services described herein, and ST assumes no
liability whatsoever relating to the choice, selection or use of the ST products and services described herein.
No license, express or implied, by estoppel or otherwise, to any intellectual property rights is granted under this document. If any part of this
document refers to any third party products or services it shall not be deemed a license grant by ST for the use of such third party products
or services, or any intellectual property contained therein or considered as a warranty covering the use in any manner whatsoever of such
third party products or services or any intellectual property contained therein.
UNLESS OTHERWISE SET FORTH IN ST’S TERMS AND CONDITIONS OF SALE ST DISCLAIMS ANY EXPRESS OR IMPLIED
WARRANTY WITH RESPECT TO THE USE AND/OR SALE OF ST PRODUCTS INCLUDING WITHOUT LIMITATION IMPLIED
WARRANTIES OF MERCHANTABILITY, FITNESS FOR A PARTICULAR PURPOSE (AND THEIR EQUIVALENTS UNDER THE LAWS
OF ANY JURISDICTION), OR INFRINGEMENT OF ANY PATENT, COPYRIGHT OR OTHER INTELLECTUAL PROPERTY RIGHT.
UNLESS EXPRESSLY APPROVED IN WRITING BY TWO AUTHORIZED ST REPRESENTATIVES, ST PRODUCTS ARE NOT
RECOMMENDED, AUTHORIZED OR WARRANTED FOR USE IN MILITARY, AIR CRAFT, SPACE, LIFE SAVING, OR LIFE SUSTAINING
APPLICATIONS, NOR IN PRODUCTS OR SYSTEMS WHERE FAILURE OR MALFUNCTION MAY RESULT IN PERSONAL INJURY,
DEATH, OR SEVERE PROPERTY OR ENVIRONMENTAL DAMAGE. ST PRODUCTS WHICH ARE NOT SPECIFIED AS "AUTOMOTIVE
GRADE" MAY ONLY BE USED IN AUTOMOTIVE APPLICATIONS AT USER’S OWN RISK.
Resale of ST products with provisions different from the statements and/or technical features set forth in this document shall immediately void
any warranty granted by ST for the ST product or service described herein and shall not create or extend in any manner whatsoever, any
liability of ST.
Information in this document supersedes and replaces all information previously supplied.
The ST logo is a registered trademark of STMicroelectronics. All other names are the property of their respective owners.