Professional Documents
Culture Documents
Process Documentation
Doc 001
MIS002-050 MIS for programming Version 10-May-18
of SANDS 1010 HS 8GB MRI Doc Date 1 of 13
Page
Table of Contents
1 Purpose________________________________________________________________2
2 Scope__________________________________________________________________2
3 Definition(s) & abbreviation(s)______________________________________________2
4 Reference(s)_____________________________________________________________2
5 MRI Preparation_________________________________________________________2
5.1 Prerequisites_______________________________________________________________2
5.2 Preparing MRI_____________________________________________________________3
5.3 Copying Files form MRI_____________________________________________________8
6 NOTE_________________________________________________________________11
2 Scope
The scope of this document is to mention about Preparing Sands 8 GB MRI and copy to / from
operation from MRI.
4 Reference(s)
Document No. BC
MRI User Manual Ver General specification of 8 GB Sands MRI
4.7.pdf
RNDIS- Lincom Driver Installation Doc
Installation.doc
5 MRI Preparation
The process of MRI preparation is very simple. Just select copy & paste the desired files in MRI
from PC. In this operation one utility called Lincom will execute at PC & USB cable is
connected between PC & MRI .Once they are connected the data can be transferred between
them.
5.1 Prerequisites
For programming the MRI with respective products like SMILE, following steps need to
perform (Here we are illustrating steps for Smile program, similar kind of steps to perform for
other programs like Dispupd, LibHHU etc).
RNDIS-Installation.d
oc
8) Press OK button
12) Press cancel if proper date time reflects without any time drift.
1. Press “Esc” button, then Prepare “SEMS” Folder in MRI in B: drive. To create the
specified folder write command “MD SEMS”. as shown below
5. Click on export button and select the both files from ‘For SANDS 1010 HS 8GB’
folder and copy to B:\ drive. As shown below
2. Tools - To get MRI serial no & to check battery & memory status of MRI
Open the “mrimenu.mnu” in notepad++ or TextPad. Below screen will get Appear.
Write below Command Line in “mrinemu.mnu” file and Load into MRI “B:\drive”. And Now power OFF
and ON MRI.