Professional Documents
Culture Documents
PILOT’S GUIDE
COPYRIGHT INFORMATION
©2015-2017 Appareo Systems, LLC. All rights reserved.
The content of this guide is furnished for informational use only, is subject
to change without notice, and should not be construed as a commitment
by Appareo Systems, LLC. Appareo assumes no responsibility or liability
for any errors or inaccuracies that may appear in the information content
contained in this guide.
Appareo, Appareo Systems, and the Appareo logo are either registered
trademarks or trademarks of Appareo Systems, LLC. All other trademarks
and registered trademarks are the sole property of their respective
owners.
• Use a dry cloth to clean Stratus ES/ESG. If necessary, you can use
a lightly damp cloth with a solution of mild detergent. Do not use
cleaners containing ammonia, acetone, or other strong acids or
bases to clean the Stratus ES/ESG display or faceplate.
1
1. About Stratus ES/ESG
Stratus ES/ESG by Appareo is an ADS-B Out transponder designed to
help pilots meet the FAA 2020 mandate. Stratus ES/ESG responds to
legacy Mode A/C interrogations and Mode S interrogations from both
ground radar and airborne collision avoidance systems. Stratus ES/ESG
are 1090 ES transponders, where Stratus ES connects to an external
GPS and Stratus ESG has a certified WAAS GPS in the same box.
(3 G) "
STRATUS /
• FIN: r1 PWR,
13138 ~El~
C2J C!J CD CD CD 0 CD CD CD CD co 0
2.1. Usage limitations
There are no limitations associated with the usage of Stratus ES/ESG.
Indicator Meaning
ADS-B transmission contains GPS position information with a
-<:> radius of containment under 1 nautical mile.
A response was transmitted from a Mode A/C/S interrogation.
4D The indicator will time out if another reply does not occur
within one second.
A built-in-test (BIT) has failed. See Section 4 for more
A information about BIT failures.
2
2.4. Mode selection keys
Use the mode selection keys to change the transponder mode. The table
below describes each of these modes.
-$-0
ALT 1234 PRESSALT
FL120
GPS screen: Displays the aircraft’s GPS position in degrees latitude and
longitude. If no GPS signal is being received, the latitude and longitude
fields will be replaced by dashes.
-$-0 LAT/LON
ALT 1234 46°54.2N
136°48.6E
3
Flight ID screen: Displays the currently entered Flight ID.
-$0
ALT 12 34 FLIGHT ID
N9999ZZZ
IHALT
1. Press FUNC or the arrow keys until “Flight ID” appears. The
previously entered flight identification number will be displayed on
the Flight ID screen.
2. Press ENT.
NOTE: If the new flight ID is less than 8 digits and there are
characters from the previously entered flight ID remaining after the
new flight ID has been input, insert spaces in those fields to overwrite
the characters.
4. Troubleshooting
Use the table below to troubleshoot possible problems with
Stratus ES/ESG.
6
The screen displays a BIT The Stratus ES/ESG screen might display a
failure warning message with the instructions below.
Below is guidance regarding how to assess the
The display screen will failure:
display a warning message
and a degraded state
V • PRESS FUNC TO CLEAR: A non-critical
indicator in the event that error has been detected. Stratus ES/ESG
any of Stratus ES/ESG’s BITs will run in a degraded state until the error
fail. is resolved. Contact your dealer for further
assistance.
• PLEASE RESTART UNIT: A critical
error has been detected. Restarting the unit
might fix the error. If the message returns
after restarting, contact your dealer for further
assistance.
• PLEASE SHUTDOWN UNIT: A critical
error has been detected. Power off the unit and
do not power it back on. Contact your dealer
for further assistance.
• WAITING TO BE UNSTUCK: A key has
been depressed for more than 20 seconds. If a
key is stuck, try to unstick the key.
• WAITING FOR RELEASE: The
external suppression input is constantly in
a suppressed state. Contact your dealer for
further assistance.
• ATTEMPTING TO RECOVER: A squitter
rate error has been detected. The transponder
may recover itself, but if it does not, restart the
unit. If the message returns after restarting,
contact your dealer for further assistance.
7
This page intentionally left blank
8
SUPPORT
Have questions? View our FAQs at http://www.appareo.com/support/
stratus/stratus-support-faq. Otherwise, contact your authorized Appareo
dealer for product support and information about servicing
Stratus ES/ESG.
FCC INFORMATION
Stratus ES/ESG has an FCC ID of 2AETC-1505005.