Professional Documents
Culture Documents
DLC-GROUT C100
Revision date : 2021/10/01 Page: 1/11
Version: 1.1 (30000001/SDS_GEN_CA/EN)
1. Identification
DLC-GROUT C100
Recommended use of the chemical and restriction on use
Recommended use*: for industrial and professional users
* The “Recommended use” identified for this product is provided solely to comply with a Federal requirement and is not part
of the seller's published specification. The terms of this Safety Data Sheet (SDS) do not create or infer any warranty, express
or implied, including by incorporation into or reference in the seller's sales agreement.
Company:
DOHA LOGIK COMPANY
Doha - State of Qatar
Email: XXXX@XXXXXXXX.com
Name : XXXXXX
2. Hazards Identification
Precautionary Statements
(Prevention):
Signal Word: P280 Wear protective
Danger P260 Do not breathe
P270 Do not eat, drink
Hazard Statement: P264 Wash with plent
Precautionary Statements
(Response):
P305 + P351 + P338 IF IN EYES: Rin
contact lenses,
P310 Immediately cal
P304 + P340 IF INHALED: Re
breathing.
P303 + P352 IF ON SKIN (or
P332 + P313 If skin irritation o
P362 + P364 Take off contam
Precautionary Statements
(Storage):
P403 + P233 Store in a well-v
P405 Store locked up
Precautionary Statements
(Disposal):
P501 Dispose of cont
point.
If applicable
information is
provided in this
section on other
hazards which
do not result in
classification
but which may
contribute to
the overall
hazards of the
substance or
mixture.
Labeling of special
preparations (GHS):
In combination with
water, repeated or
prolonged dermal
exposure can cause
moderate to severe
alkali burns.
3. Composition /
Safety Data Sheet
DLC-GROUT C100
Information on medical attention. Do
Ingredients not induce vomiting
unless told to by a
According to Hazardous poison control center
Products Regulations or doctor.
(HPR) (SOR/2015-17)
If inhaled:
After inhalation of
dust. Keep patient 5. Fire-Fighting Measures
calm, remove to fresh
air. If difficulties occur: Extinguishing media
Obtain medical
attention. Suitable extinguishing media:
foam, water spray, dry
If on skin: powder, carbon dioxide
After contact with
skin, wash Unsuitable extinguishing
immediately with media for safety reasons:
plenty of water and water jet
soap. Under no
circumstances should Additional information:
organic solvent be Product itself is non-
used. If irritation combustible. Only the
develops, seek packaging materials
medical attention. can catch fire. The
extinguishing agents
If in eyes: normally used are
Wash affected eyes for sufficient.
at least 15 minutes
under running water
with eyelids held open,
consult an eye
specialist.
Special hazards arising
If swallowed: from the substance or
Rinse mouth mixture
immediately and Hazards during fire-fighting:
then drink plenty of carbon monoxide, carbon
water, seek dioxide, harmful vapours
Evolution of fumes/fog.
Safety Data Sheet
DLC-GROUT C100
The substances/groups of. Pack in tightly closed
of substances mentioned containers for disposal.
can be released in case F
of fire. Product is not o
combustible or r
explosive.
r
Advice for fire-fighters e
Protective equipment for s
fire-fighting: i
Wear self-contained d
breathing apparatus and u
chemical-protective e
clothing. s
:
Further information:
Product itself is non- R
combustible; fire i
extinguishing method of n
surrounding areas must s
be considered. The e
degree of risk is governed
by the burning substance w
and the fire conditions. i
Dispose of fire debris and t
contaminated h
extinguishing water in
accordance with official p
regulations. l
e
n
t
6. Accidental release y
measures
o
Personal precautions, f
protective equipment
and emergency w
procedures a
Avoid dust formation. t
Avoid contact with skin e
and eyes. Use personal r
protective clothing. .
Handle in accordance
with good building A
materials hygiene and v
safety practice. o
i
Environmental d
precautions
r
Do not discharge into
a
drains/surface
i
waters/groundwater.
s
i
Methods and material n
for containment and g
cleaning up
For small amounts: Pick up d
with suitable appliance and u
dispose of. s
For large amounts: Pick t
up with suitable .
appliance and dispose
Safety Data Sheet
DLC-GROUT C100
7. Handling and Storage /01 P
Version: 4.1 a
Precautions for safe g
8. Expos e:
handling ure 5/
Avoid dust formation.
The Cement contained Contro 1
ls/Pers 1
in this product reacts
onal (
alkaline when in
3
contact with water or Protec 0
humidity. This may tion 0
cause severe irritation
0
of skin or mucous
Comp 0
membranes. The
onent 0
humidity of the skin or
s with 0
mucous membranes is
occup 1/
enough for this
ational S
reaction. Prolonged
expos D
direct contact to the
ure S
dry product should be
limits _
avoided therefore.
G
Avoid inhalation of
E
dusts. Avoid skin
N
contact. Pour
_
downwind and allow as
C
little free fall as
A
possible while
/
emptying bags into
E
equipment. Breathing
N
must be protected
)
when large quantities
are decanted without calcium oxide OSHA PEL
local exhaust ACGIH TLV
ventilation.
Limestone OSHA PEL
Protection against fire and
explosion:
No special precautions
necessary.
Revision 202
date : 1/10
Safety Data Sheet
DLC-GROUT C100
100% SiO2. Lower percentages of SiO2 will yield
m
higher
TWA value e
The exposure limit is calculated from the
n
equation, 30mg/m3)/(%SiO2+2), using a value of
100% SiO2. Lower percentagest of SiO2 will yield
higher
ACGIH TLV TWA value
R
Cement, portland, OSHA PEL PEL e
chemicals Respirable fraction
Total dust s
fraction p
cubic foot
ACGIH TLV TWA i
The value is for particulate matter
r containing no
asbestos
R P a
e
V a t
e
o
Advice on system design:
Provide local exhaust r
ventilation to maintain y
recommended P.E.L.
P p
e r
r o
s t
o e
n c
a t
l i
o
p n
r :
Breathing protection if dusts
o are formed.
t
Hand protection:
e Chemical resistant
c protective gloves,
Manufacturer's directions
t for use should be
i observed because of
great diversity of types.
v
e Eye protection:
Tightly fitting safety goggles
(chemical goggles).
e
Body protection:
q Body protection must be
chosen based on level of
u
activity and exposure.
i
General safety and hygiene
p
measures:
Safety Data Sheet
DLC-GROUT C100
Avoid contact with the Bulk density: approx. 1,2
skin, eyes and clothing. Vapour density: No applicab
Avoid inhalation of dusts. Partitioning coefficient n- not applica
In order to prevent octanol/water (log Pow):
contamination while Thermal decomposition: No decomp
handling, closed working prescribed/
clothes and working Viscosity, dynamic: No applicab
gloves should be used. Viscosity, kinematic: No applicab
Handle in accordance Solubility in water: ( 15 °C)
with good building not soluble
materials hygiene and Miscibility with water: ( 20 °C)
safety practice. When immiscible
using, do not eat, drink Solubility (quantitative): No applicab
or smoke. Hands and/or Solubility (qualitative): No applicab
face should be washed Evaporation rate: No applicab
before breaks and at the
end of the shift. At the
end of the shift the skin 10. Stability and Reactivity
should be cleaned and
skin-care agents applied. Reactivity
Gloves must be No hazardous reactions if
inspected regularly and stored and handled as
prior to each use. prescribed/indicated.
Replace if necessary
(e.g. pinhole leaks). Corrosion to metals:
Remove contaminated No corrosive effect on metal.
clothing immediately and
clean before re-use or Oxidizing properties:
dispose it if necessary. Based on its structural
a o
s f
p w
r a
e t
s e
c r
r .
i
b Conditions to avoid
e Avoid dust formation. Avoid
d humidity.
/
i Incompatible materials
n strong bases, strong acids
d
i Hazardous
c decomposition products
a
t Decomposition products:
e No hazardous decomposition
d products if stored and
. handled as
prescribed/indicated.
S
t Thermal decomposition:
r No decomposition if stored
o and handled as
n prescribed/indicated.
g
b
a 11. Toxicological
s information
e
s Primary routes of
exposure
a
r Routes of entry for solids
e and liquids are ingestion
and inhalation, but may
f include eye or skin
o contact. Routes of entry
r for gases include
Safety Data Sheet
DLC-GROUT C100
inhalation and eye r
contact. Skin contact
may be a route of entry a
for liquefied gases. c
u
R P t
e
V a e
e
A e
c f
ut f
e e
T c
o t
xi s
ci
A
ty s
/E s
ff e
ec s
ts s
m
Acute toxicity e
Assessment of acute n
toxicity: Virtually t
nontoxic after a single
ingestion. Virtually o
nontoxic after a single f
skin contact. Virtually
nontoxic by inhalation. S
The product has not T
been tested. The O
statement has been T
derived from the
properties of the s
individual components. i
n
Oral g
No applicable information l
available. e
:
Inhalation Causes temporary irritation of
No applicable information the respiratory tract.
available.
12. Ecological w
Information
s
Toxicity
Aquatic toxicity t
Assessment of aquatic
toxicity: h
There is a high probability
that the product is not i
acutely harmful to aquatic
organisms. s
The product gives rise to
pH shifts. Based on
available Data, the
classification criteria are not p
met.
r
Persistence and
degradability o
Assessment biodegradation d
and elimination (H2O)
Inorganic product u
which cannot be
eliminated from water c
by biological
purification processes. t
The product is slightly
soluble in water. It can
be largely eliminated
from the water by t
abiotic processes,
e.g. mechanical separation. o
x b
p e
r i
i n
e e
n r
c t
e
a
n
Safety Data Sheet
DLC-GROUT C100
d o
n m
o a
n t
- i
d o
e n
g not determined
r Bioaccumulative
potential
a
Assessment bioaccumulation
d potential
The product will not be
a readily bioavailable due to its
consistency and insolubility in
b water.
l Mobility in soil
e Assessment transport
between environmental
. compartments
The substance will not
evaporate into the
atmosphere from the water
E surface.
Following exposure to
l soil, adsorption to solid
soil particles is probable,
i therefore contamination
of groundwater is not
m expected.
R P
i e
V a
e g
n Ad e
diti :
a on
al 1
t inf 0
or /
i 1
ma
tio 1
o
n
(
n 3
0
0
0
i 0
0
n 0
1
f
Safety Data Sheet
DLC-GROUT C100
/ 15. Regulatory Information
S
Other ecotoxicological
advice: Q
Do not discharge product
into the environment a
without control. The
product has not been t
tested. The statements
on ecotoxicology have a
been derived from the
properties of the r
individual components.
R
13. Disposal
considerations e
g
Container disposal:
Completely emptied u
packagings can be given for
recycling. l
a
14. Transport Information
t
L i
a
n o
d Not classified as
tr a dangerous n
a good under
n transport s
s regulations
p
o
rt R
T
D e
G
g
Se i
a
tra s
ns Not classified
po as a dangerous
t
rt good under
IM transport
r
D regulations
G
a
Air t
tra
ns i
po Not classified
rt as a dangerous o
IAT good under
A/I transport n
CA regulations
O
Safety Data Sheet
DLC-GROUT C100
1
s /
1
t 0
/
a 0
1
t
u We support worldwide
Responsible Care
s initiatives. We value the
health and safety of our
: employees, customers,
Chemical released / listed suppliers and neighbors,
and the protection of the
environment. Our
commitment to
16. Other Information Responsible Care is
integral to conducting our
SDS Prepared by: business and operating
D our facilities in a safe and
L environmentally
C responsible fashion,
supporting our customers
P and suppliers in ensuring
r the safe and
o environmentally sound
d handling of our products,
u and minimizing the impact
c of our operations on
t society and the
environment during
R production, storage,
e transport, use and disposal
g of our products.
u R P
l e a
2
a
0
t
i
o END OF DATA SHEET
n
s
S
D
S
P
r
e
p
a
r
e
d
o
n
:
2
0
2