Professional Documents
Culture Documents
v2.0
Tube Screamer
TS808 / TS9
For two extra settings use both cap spots I’ve got lots of empty pads!
and a SPDT ON-OFF-ON switch.
You sure have. The board is designed so
you can make a Dumb Lloyd on it. That
Recommended values are 47n for much
has parts that aren’t on the TS. Don’t
more bass, 22n for a little more bass, or
worry about it.
use both if you’re going for two settings.
C7 and C12 can lay flat as shown on the image so there’s more clearance in the box.
Test the board!
BATTERY
BOARD
GND
OUT
BOARD
OUT
BOARD
GND
IN +
L
LE
ED BOARD
+
D LED+
BOARD
9V
BOARD
GND BATTERY
Wiring shown above will disconnect the battery when you remove the jack
plug from the input, and also when a DC plug is inserted.
The Board GND connections don’t all have to directly attach to the board. You
can run a couple of wires from the DC connector, one to the board, another to
the IN jack, then daisy chain that over to the OUT jack.
It doesn’t matter how they all connect, as long as they do.
This circuit is standard, Negative GND. Your power supply should be Tip
Negative / Sleeve Positive. That’s the same as your standard pedals (Boss etc),
and you can safely daisy-chain your supply to this pedal.
PedalParts.co.uk