You are on page 1of 1

- + OFF START OFF START OFF START OFF START

ACC RUN ACC RUN Key in


1 ACC RUN
1.3K Ohm
Theft ACC RUN
Ignition Resistor

2 Ignition
Switch
Run/Crank
Relay
3

4
Park Body
P Neutral Control
5 1
R 2 (PNP) Switch Module
N D A/T Start
Inhibit
Switch
Manual
6 Ign Transmission Data
Fuse Starter
Fuse Bus
Clutch Switch M/T
10

Starter Theft
PCM
Relay Detterrent 7
Module

8
9
11
Pull-in
Coil Hold
Coil Starter Motor
12 Solenoid
13

1). Key is inserted into lock cylinder and signals BCM (1).
2). User turns key to START. Power flows through theft resistor (2) to change voltage input to BCM.
3). BCM provides power to the Run/Crank relay control circuit (3).
4). Relay operates and closes switch contacts (4) to provide power to Park/Neutral (PNP) switch (5). If PNP is in PARK
or NEUTRAL, power flows through ignition fuse (5) to STARTER RELAY control circuit (6).
5) Theft Deterrent Module (TDM) (7) interrogates transponder key and retrieves password. TDM sends password to
PCM. If password is correct, PCM provides ground to starter relay control circuit (8).
6). Starter relay energizes and closes contacts (9).
7). Power flows from battery through starter fuse (10), contacts (9) and to start solenoid (11).
8). Starter solenoid closes contacts (12) providing battery power to starter motor (13).
9). Engine cranks.
© 2012 Rick Muscoplat

You might also like