Professional Documents
Culture Documents
Overhead Panel:
BATT 1+2 ON
External Power ON
ADIRS 1+2+3 NAV
Ground Switch ON
Crew Supply ON
CVR TEST
Strobe Lights ARM
NAV & Logo Lights ON
Seatbelt Signs ON
No Smoking Signs AUTO
Emergency Exit Lights ARM
APU Fire Test PERFORM
Engine Fire Test 1+2 PERFORM
APU Master SW ON
APU Start ON
- MCDU -
Load Simbrief-Flightplan:
Check: MCDU MENU > OPTIONS > AOC > SIMBRIEF > your USER NAME
MCDU MENU > ATSU > AOC MENU > INIT/PRES > INIT DATA REQ
AOC MENU > PERF/W+B > REFUEL *LOAD > Next Page > PAYLOAD *LOAD
INIT > INIT REQUEST* > Next Page > ZFW/ZFWCG (2x push) > BLOCK (fuel)
MCDU MENU > ATSU > AOC MENU > WX REQUEST > SEND > AOC MENU > upper ECAM
message „COMPANY MSG“ check > AOC MENU Page > RECEIVED MESSAGES > METAR >
PRINT
F-PLN > select Departure Airport > DEPARTURE > select Rwy > select SIDS > INSERT
select Destination Airport > ARRIVAL > select Rwy > select STARS > select APPR VIAS
(Transition) > INSERT
RAD NAV > set VOR/LS/ADF Frequencies (look in the charts > Navigraph)
PERF > set FLAPS / THS to 1/0.7DN > set FLEX TO TEMP 60 or 50 (very good and good
weather conditions), set 40 (bad weather conditions) > push V1 VR V2 (Takeoff speeds) > TRANS
ALT (look in the charts > Navigraph)
Light up the screens (Primary Flight Display, Navigation Display, ECAMs, MCDU
Enter Frequencies (VATSIM, IVAO ...) > set Transponder AUTO / ON
Set QNH > set FD / CSTR (FCU both sides, GREEN) > set ADF/VOR Switches
FUEL PUMPS ON
EXT POWER OFF
APU BLEED ON
AIR CONDITION (set Cockpit / FWB/AFT Cabin)
Beacon Light ON
End Pushback
Noselight TAXI
Outside check (clear left/right side)
Parking Brake OFF
- Start Taxi -
Brake check > check „Brake Pressure Indicator“ > PRESSURE ZERO
Autobrake MAX
Predictive Windshear ON
Overhead Panel > CALLS > push ALL
push T/O Config Button
- Holding Position -
Parking Brake SET ON
Weather Radar ON
TCAS TA or TA/RA
Stobes ON
Nosewheel Lights TO
- Take-Off -
Runway Turnoff Lights ON
Landing Lights ON
Chrono START
Brakes AS RQRD
Engines STABILIZE 50% N1
Thrust FLX/MCT or TOGA