You are on page 1of 2

Quick Start Guide IMPORTANT SAFETY INFORMATION LIMITED WARRANTY Multi Function

Replaceable Cap Reject incoming Call: Press the MFB button to ‘Call Rejected’ voice
and release.
For the applicable warranty terms and conditions and additional information Button (MFB) Phone Transfer: Press the MFB button for 1 second and hear the sound ‘BEEP’,
1. Read these instructions. 10. Please store this product in a clean Microphone
it will transfer the current call between LIFE BUDS and phone.
and dry environment. regarding Music Tribe’s Limited Warranty, please see complete details online at LED (Do NOT press the MFB so quickly, or it will hang up)
2. Keep these instructions.
11. Charge it once a month musictri.be/warranty. Call Mute Mode: Double-press the MFB button to mute/unmute voice.
3. Heed all warnings.
(minimum). Note: Only the Right LIFE BUD has the calling function when both LIFE BUDS
4. Follow all instructions.
12. WARNING! Choking and
Accessories List are used.
5. Do not use this apparatus
near water.
Swallowing Hazard. Keep the • LIFE BUDS x 1 pair Bluetooth Version: 5.0. Enjoy a true high-definition stereo music experience! LIFE BUDS Reset: Put the LIFE BUDS in the charging case, press LIFE BUD to
6. Clean only with dry cloth.
product safely out of reach of
children and pets. The small size
• Charging Case Each LIFE BUD has a single multi-function button (MFB) control, a microphone, charging status(red LED on), double-press the MFB button, LIFE BUD reset
and an LED indicator. Various cap sizes allow you to choose the most successfully after blue LED flashes 5 times, then do same for the other one.
7. Do not throw this product in and the internal battery present a • Charging Cable comfortable fit and find the best sound quality.
the fire, to avoid explosion. choking and swallowing hazard. • This Quick Start Guide Use both LIFE BUDS together, or as single units. LIFE BUD Charging
8. Do not expose this product to
Failure to follow instructions
may lead to permanent damage
• Storage Bag 1. The Red LED on the LIFE BUDS flashes when the power is low. Please charge
bright sunshine for a long time. or death. • Caps of various sizes GETTING STARTED the LIFE BUDs soon.
9. Do not disassemble or modify Before use, please read this quick start guide carefully and keep it in a safe place. 2. Put the LIFE BUDS in the charging case, close the lid, and the LIFE BUDS will
13. WARNING! To prevent possible FEATURES start charging (red LED on).
this product. hearing damage, do not listen Please fully charge the LIFE BUDS before use.
at high volume levels for Please regularly charge the LIFE BUDS if you do not use them for a long time 3. The LIFE BUD LED will turn off automatically when it is fully charged.
Lid
long periods. (more than 3 months). Please use the supplied charger cable.
Front Rear Status LEDs
LIFE BUDS LEGAL DISCLAIMER
General Operation Charging Case LEDs
Auto Power on/off: Open/Close the lid, LIFE BUDS power on/off automatically. Blue LED on: Above 50% charged.
Audiophile Wireless Earbuds with Music Tribe accepts no liability for any loss which may be suffered by any person Left Charging Port Bluetooth Pairing: Pairing is Automatic. Red LED on: 25%-50% charged.
who relies either wholly or in part upon any description, photograph, or statement Right
Immersive Single Point Source Audio Charging Status LEDs (Micro USB) Shutdown: Press the MFB button until the red LED is on. Red LED flash: Below 25% charged.
contained herein. Technical specifications, appearances and other information Answer incoming call/Hang up: Press the MFB button. Note: If the charging case LEDs are not on when the LIFE BUDS are first
are subject to change without notice. All trademarks are the property of their Play music/Pause: Press the MFB button. inserted, open the charging case lid and make sure the LIFE BUDS are in the
respective owners. Midas, Klark Teknik, Lab Gruppen, Lake, Tannoy, Turbosound, The charging case includes an internal battery that charges the LIFE BUDS when correct position.
the lid is closed. They can be charged up to 3 times before the charging case has Next music track: Double press the Left MFB button.
TC Electronic, TC Helicon, Behringer, Bugera and Coolaudio are trademarks or
to be recharged. Connect the supplied charging cable to the rear connector on Previous music track: Double press the Right MFB button.
registered trademarks of Music Tribe Global Brands Ltd. the case to recharge from a USB port. The front LEDs show the charging status
© Music Tribe Global Brands Ltd. 2018 All rights reserved. Hearing Aid: Triple-press the MFB button to turn on/off hearing-aid.
of the LIFE BUDS inside.
LIFE BUD LEDs Using a single LIFE BUD Channel No. 79 Other important information installation. This equipment generates, uses and can radiate radio frequency
Max Output Power 10 dBm energy and, if not installed and used in accordance with the instructions,
Red LED flashing: The battery charge is low. 1. Make sure both LIFE BUDS are inside the case, and your phone or other 1. Register online. Please register your new Music Tribe equipment right may cause harmful interference to radio communications. However, there is no
Red LED on: Charging (when in the charging case). device’s Bluetooth is turned off . after you purchase it by visiting tannoy.com. Registering your purchase using our guarantee that interference will not occur in a particular installation.
LIFE BUDS Performance
Red LED on momentarily: Power turned off. 2. Open the lid and take out the Right LIFE BUD. The LED will flash blue simple online form helps us to process your repair claims more quickly and efficiently.
Output 10 mW If this equipment does cause harmful interference to radio or television
Blue LED flashing very slowly: The LIFE BUDS are working. and red. (If using the Left LIFE BUD instead , first press MFB until the Also, read the terms and conditions of our warranty, if applicable. reception, which can be determined by turning the equipment off and on,
Blue and red LED flashing: LIFE BUDS pairing. LED flashes blue and red.) Frequency Response 20 Hz to 20 kHz the user is encouraged to try to correct the interference by one or more of the
2. Malfunction. Should your Music Tribe Authorized Reseller not be located in your
3. Turn on the Bluetooth mode on your phone or device, and search for the LIFE vicinity, you may contact the Music Tribe Authorized Fulfiller for your country listed under following measures:
Using both LIFE BUDS BUD on the screen. Click and connect it. When connected successfully, the Battery (LIFE BUDS)
There are two methods to set up the LIFE BUDS, and each may be used: LED will flash blue slowly. Capacity 3.7 V/50 mAh
“Support” at tannoy.com. Should your country not be listed, please check if your problem • Reorient or relocate the receiving antenna.
Charging time (approximately) 1 hour
can be dealt with by our “Online Support” which may also be found under “Support”
at tannoy.com. Alternatively, please submit an online warranty claim at tannoy.com
• Increase the separation between the equipment and receiver.
Method one Troubleshooting tips
Usage time (approximately) BEFORE returning the product.
• Connect the equipment into an outlet on a circuit different from that to
1. Make sure both LIFE BUDS are inside the case, and your phone or other which the receiver is connected.
1. If your phone cannot find the LIFE BUDS, please check that the LIFE BUDs are
device’s Bluetooth is turned off . on matching(blue and red LED flashing). If the LIFE BUDs are not matched
Music playback 4 hours • Consult the dealer or an experienced radio/TV technician for help.
2. Open the lid and the LIFE BUDS will auto-power on and enter pairing mode. for a long time, please turn on the LIFE BUDS to match again, or press Phone calls 4 hours FEDERAL COMMUNICATIONS This equipment complies with Part 15 of the FCC Rules. Operation is subject to
3. The left LIFE BUD will flash blue, and the right will flash blue and red and around three seconds until LED flashes blue and red. Sometimes it is better Standby 120 hours COMMISSION COMPLIANCE INFORMATION the following two conditions:
wait for the connection with your phone or device. to reset the LIFE BUDS and the Bluetooth function of the phone. (1) This device may not cause harmful interference, and
2. If it is not possible to talk or listen to music while connected successfully: Charging Case (2) This device must accept any interference received, including interference
4. Turn on the Bluetooth mode on your phone or device, and search for the
LIFE BUD on the screen. Click and connect it. When connected successfully, You might need to choose Bluetooth “Mobile Audio” or “Media Audio” when Battery capacity 3.7 V/450 mAh that may cause undesired operation.
the LEDs on both LIFE BUDS will flash blue slowly. using an Android system, or please choose Bluetooth on call interface. Charging time (approximately) 2 hours LIFE BUDS This transmitter must not be co-located or operating in conjunction with any
3. If your phone or device is paired/connected with the LIFE BUDS but there is LIFE BUD recharges 3 full charges other antenna or transmitter.
Method two no sound: Try removing the LIFE BUDS as a Bluetooth device and then pair
1. Make sure both LIFE BUDS are inside the case, and your phone or other with your phone or device a second time. Power input Micro USB, 5 V / 1 A Responsible Party Name: Music Tribe Commercial NV Inc. Caution!
device’s Bluetooth is turned off . Address: 5270 Procyon Street The Music Tribe is not responsible for any radio or TV interference caused by
Specifications Physical Las Vesgas, NV89118
2. Open the lid and take out the Right LIFE BUD. The LED will flash blue and red unauthorized modifications to this equipment.
Operating temperature -100C to 500C USA
and wait for the connection with your phone or device. Bluetooth Such modifications could void the user authority to operate the equipment
3. Turn on the Bluetooth mode on your phone or device, and search for the Dimensions (charging case) 68.5 x 32 x 33.5 mm Phone Number: +1 702 800 8290
Bluetooth version V 5.0 (2.7 x 1.26 x 1.32") FCC RF Radiation Exposure Statement:
LIFE BUD on the screen. Click and connect it. When connected successfully, Wireless range 10 meters (with no obstacles)
the LED will flash blue slowly. The first LIFE BUD is connected. Weight (including charging case) 43 g (0.09 lbs) LIFE BUDS (1) This Transmitter must not be co-located or operating in conjunction with any
Support model HSP / HFP / A2DP / AVRCP This equipment has been tested and found to comply with the limits for a ClassB other antenna or transmitter.
4. Take out the Left LIFE BUD. The LED will flash blue once, and it will be (2) This equipment complies with FCC RF radiation exposure limits set forth for
connected automatically. Frequency Range 2402 to 2480 MHz digital device, pursuant to part 15 of the FCC Rules. These limits are designed
to provide reasonable protection against harmful interference in a residential an uncontrolled environment.

You might also like