Professional Documents
Culture Documents
1-Fresno StateTIDS Ver 9 12-2-15
1-Fresno StateTIDS Ver 9 12-2-15
(Version 10)
IF YOU HAVE ANY QUESTIONS OR COMMENTS ABOUT THIS INSTALLATION GUIDE PLEASE VISIT
THE COMPLETE TELECOMMUNICATIONS INFRASTRUCTc665SIGNTS
Version 10
ADDENDUM 3. ..................................................................................................................................................... 61
time to validate the test results and insure that all testing is complete prior to placing copper
and fiber into service. All copper horizontal station cable and fiber optic cable testing will
comply with (TIA) ANSI/TIA/EIA-568-B.1 or (ISO) ISO/IEC 11801 Ed.2 Industry Standards, and be
done using a current, certified and calibrated Fluke test instrument. Copper tie-cables and OSP
E. Finishes
4.0 PLUMBING
4.1 Piping Coordination through Telecommunications Rooms (EIA/TIA 569-A 8.2.5.2)
Piping and plumbing unrelated to telecom (other than what is required to support the room such as
chilled water supply/return) shall not be routed
Initial Release November 26, 2012 TEST INDEX Page 2nitial Rei-8(e N)4(o)2Ib
Version 10
Note:
2.
To extend into a building beyond 50 ft., the conduit entering the wall or
concrete floor slab needs to be extended with IMC or RMC conduit. This
allows the entrance point to move from the wall or concrete slab. The
50-
devices requires access to the horizontal cabling via a cord plugged into the telecommunicationl
outlet located within the work area.
7.
If a large number of such outle 10ts are required, the designer should consider the use of cast
-in-
place floor boxes with feeder duct (Walkerduct) ser a-3() )-77(se3(mulsbTJ>>
)-tis )-pl(flo)-3
tsJETBT1 0 0 1 51777 53 bb
place
6lace ETBT1/F510.98 Tf1 0 l
Version 10
Outlet Labeling
Each faceplate shall be labeled with ROOM, FACEPLATE NUMBER, and JACK position.
Example: 361.02A for each cable.