Professional Documents
Culture Documents
YUKON
Tall Floor Split Systems
36,000 - 90,000 Btu
Cooling Only
MCV Series 50/60 Hz
50 Hz Models
Cooling Only
MCV 036 AB
MCV 048 AB
MCV 060 AB
MCV 090 AB
60 Hz Models
Cooling Only
MCV 036 A1
MCV 048 A1
MCV 060 A1
MCV 090 A1
2
© American Standard Inc. 1999 MS-SVU002-EN
Contents
General Information 2
Control Operation 4
System Operation 5
Maintenance 6
Troubleshooting 7
MS-SVU002-EN 3
Control Operation
ROOM TEMP
HIGH
MEDIUM
LOW
SET TEMP
23 24 25 26 27 ROOM TEMP
4 MS-SVU002-EN
System Operation
Special Features Adjust Air Flow Direction Operating Air Conditioner Safety
- The supply air grille may be - Do not insert a bar or similar
Memory adjusted left, right, up or down object into the supply air grille.
The Trane control keeps the current manually. In particular, advise small children
ON/OFF status, fan speed, and - Adjust the air flow direction not to insert anything in the grille.
temperature setting in its non-volatile properly, otherwise it may cause - Do not pour water directly on the
memory. So, if there is a brief power discomfort and make the room air conditioner to clean it. If the
interruption, the control will temperature uneven. air conditioner is operating when
automatically resume operation with wet, grounding may occur,
the same fan speed and temperature Operating Precautions damaging the unit.
setting as before the interruption. This system must be installed properly - Adjust the air flow so it does not
by a qualified installer in accordance blow directly on room occupants.
Watchdog with the installation instructions. - Do not use flammable sprays near
The microprocessor occasionally the air conditioner because of the
malfunctions due to voltage fluctuation Stop the air conditioner at once, danger of fire.
or other abnormalities. The “watchdog” if any of the following should - Do not use a steel or copper wire
circuit will reset and restart the micro- occurs: in place of fuses.
processor if this happens. - The power cord is too hot to be - Do not inspect or service the
touched by hand. air conditioner while it is operating.
Compressor Delay Protection - The insulation of the power cord is - Turn off the power supply before
exposed at any point. doing any inspection or service
Each time the compressor is off, there
- The fuse is blown or circuit breaker work.
will always be a minimum of
trips frequently. - The power cord should be kept
a 3-minute delay before
- The functions of the switches are away from furniture with sharp
the compressor can restart.
inaccurate. corners. It may cause fire or
electric shock.
Freeze Protection (Optional)
- When the air conditioner will not be
When the MCV unit is operating in cool
used for a long time, be sure to turn
mode and the temperature is very low, Up
Right OFF the power supply.
there is a chance that the coil might Left
freeze. The freeze protection function
If you have any questions or problems
will turn the compressor off and
with your air conditioning system,
operate the unit at a low fan speed in
please consult your nearest Trane
order to defrost the coil.
dealer.
Freeze protection occurs when:
- The coil temperature is less than 0OC. Down
- The compressor runs continually for
at least 10 minutes.
During the freeze protection operation:
- The fan operates at low speed AUTO
HIGH
MEDI
LOW
UM
(“Low”).
- The compressor stops functioning. POW
ER
TEMP
FAN
blinks.
Freeze protection stops when:
- The coil temperature is above 7OC.
- The unit is turned on and off.
MS-SVU002-EN 5
Maintenance
Regular Maintenance 1.2 How to clean the air filter 2. Cleaning the Front Panel
Be sure to disconnect the power Wash away dust from the air Do not pour water directly on the
before inspection or maintenance of filter with clean water or front panel to clean it. Dust or wipe it
air conditioner. vacuum it with an electric lightly with a soft cloth. If it is very
vacuum cleaner. dirty, use a soft cloth soaked in water
1. Cleaning the Air Filter or a neutral detergent.
Air flow is reduced and cooling Note: Once the air filter is washed,
efficiency impaired if the filter is dry it completely before returning it Cautions
clogged. Be sure to clean the to its original position. - Do not use water over 500C to
filter every two weeks during the clean the front panel or it may
cooling season. Cautions become discolored.
1.1 How to remove the air filters - Do not wash the air filter in water - Do not use benzine, gasoline,
- Open access panel by that is over 400C or it may shrink. thinner, polishing compound,
pulling down (Figure 2). - Do not expose the air filter to fire. machine oil, etc. when cleaning
- Pull up each air filter frame - Do not expose the air filter to direct the front panel, or paint may peel
from the return air grille sunlight for a long period of time. off, or it may become deformed
(Figure 3). - Clean the air filter more frequently or damaged.
when the air is very dirty.
Figure 2 Figure 3
6 MS-SVU002-EN
Troubleshooting
MS-SVU002-EN 7
Literature Order Number MS-SVU002-EN
Trane Thailand New
7th Floor, Ploenchit Center Building
2 Sukhumvit Road, Klongtoey Stocking Location Bangkok, Thailand
Bangkok 10110
http://www.trane.com
Since The Trane Company has a policy of continuous product improvement, it reserves the right
An American Standard Company to change design and specifications without notice.