Professional Documents
Culture Documents
Introduction
B. General Documentation
a. Network Topology
b. IP Addresses
C. Implementation
a. Screenshot of your configuration, crop your screenshot making
sure all the relevant information is captured and make a small
comment of what the screenshot is about (You must take screen
shot of the configuration process. The #showrun command can be
used in the testing phase)
b. First, set up all the basic configuration settings (IP Address, Device
Name, Routing Protocol, etc.)
IP Address: 192.168.1.5
IP Address: 192.168.1.6
IP Address: 192.168.1.7
IP Address: 192.168.1.8
IP Address: 192.168.1.9
IP Address: 192.168.1.10
IP Address: 192.168.3.5
IP Address: 192.168.3.6
IP Address: 192.168.3.7
IP Address: 192.168.3.8
IP Address: 192.168.3.9
Switch0
Switch1
Router0
Router1
c. Second, test all the basic configuration works and that you have
proper connectivity in your network
Router0 – Router1
d. Third, implement:
i. Static IP address to the switches
ii. Configure speed and duplex of the switch (For each of the
connected port, duplex: full, speed: 10 Mbps for
workstations and 100 Mbps for server and routers)
iii. Configure SNMP Protocol on the routers and switches (check
the uptime, change the name and location of each devices)
iv. Monitor the traffic coming the server using SPAN (Switched
Port Analyser)
D. Sign Off