Professional Documents
Culture Documents
Thermostat Manual
Thermostat Manual
24 VAC
2-pipe fan coil control
Data sheet
Features
• Super modern appearance design, suitable
for office, hotel and residential building
• Slim design, direct installation on 86×86mm
box or 3×3inch box
• Stylish and elegant green/blue backlight with
white colour ring
• 2-pipe integrated into one unit with easy
configuration
• Big LCD display with English and icons
• Easy to install and set-up
• Time on/off function
Application • Selectable room temperature or setpoint
application of 3-speed fan and modulating valves • Manual or automatic fan speed selection
1
Hotowell International Co., Limited|www.hotowell.com|+86-592-6538262|info@hotowell.com
Floor 10, Hailian Business Building,Haicang District, Xiamen 361026, China
Mechanical design Fan Operation
Thermostat appearance
Temperature display
Time on/off
Heat/Cool/Vent
Backlight
2
Hotowell International Co., Limited|www.hotowell.com|+86-592-6538262|info@hotowell.com
Floor 10, Hailian Business Building,Haicang District, Xiamen 361026, China
Keypad lock Freezing protection mode
The default status of ‘Keypad Lock’ is all keys Freezing protection can be disabled (default) or
available and it can be changed in ISU mode. enabled. If freezing protection is enabled (It is not
Keypad lock has the following settings: available in cool only application) and thermostat is in
All keys are available (Default) OFF mode while the room temperature is below 6 ℃,
System button is locked out the thermostat will open heating device before the
Fan and System button are locked out temperature rises to 8℃.
All buttons are locked
Operating modes
The following operating modes are available:
Comfort mode
Installation:
3
Hotowell International Co., Limited|www.hotowell.com|+86-592-6538262|info@hotowell.com
Floor 10, Hailian Business Building,Haicang District, Xiamen 361026, China
• Drafts or dead spots behind doors and in corners
Terminal Designations • Hot or cold air from ducts
• Sunlight or radiant heat from appliances
No Terminal Description • Concealed pipes or chimneys
• Unheated/uncooled areas such as an outside wall
1 R 24VAC power
8 SB Remote setback
Wiring diagrams
Step 2
Push the Power box into the junction box.
Step 3
Place Back cover over junction box, insert and
tighten mounting screws.
Installation & Commissioning
Install the thermostat about 5 feet (1.5m) above the
floor in an area with good air circulation at average
temperature.
Step 5
Align the 4 tabs on the Back cover with
corresponding slots on the back of the
thermostat, and then push it until the thermostat
snaps in place.
Installer set up
Press and simultaneously for 3 seconds to
enter ISU as below:
Press or to change settings
Press to advance to next function
Press and hold and buttons 3 seconds to exit
and save settings
Installer test
Follow the procedure below to test the heating and
cooling and fan system.
Number
Setting
System
test No.
System
status