in series and cascaded array. *This paper is used to see the power density difference in the centre and far from the centre. Novel Design *Microstrip antenna is used as a receiver of 2.45GHz to reduce substrate loss. Rectenna *Software used here is the ADS for Element and designing and optimizing Xi Li1 (Member, IEEE) Lin Yang1 and Li Huang Array for *Max RF to DC pass filter efficiency is 80% Wireless Power when input is 21dbm and 35000 resistive load. Transmission *Average of 77.2% efficiency at dc volt of 18.5v *Effectively used for wireless power transmission.
*Wearable rectenna at ultra high
frequency band is presented. *The device used here consists of patch antenna and full wave bridge rectifier UHF Wearable *They are joined using adhesive conductive Giuseppina Monti, Laura Corchia,and Rectenna On fabric on a bilayer substrate on jeans Luciano Tarricone Textile *The measurements are performed with Material an incident power density of 14uW/cm2 *The efficiency is higher than 20% over freq range 860-918MHz with max of 50% at 876MHz
*These rectennas are designed for
supplying power to dc – dc booster converter. Compact *This rectennas RF to DC conversion Rectennas for Ultra Low efficiency is higher than 25% for power Abderrahim Okba , Alexandru Takacs, density of 0.25uW/cm2 Member, IEEE, and Hervé Aubert, Senior Power *For the power density of 2.1uW/cm2 it Member, IEEE Wireless gives 37%. Transmission *Now when using the storage capacitor Application interestingly it can be used to turn an led light on. *The reconfigurable BPF uses four positiveintrinsic-negative (p-i-n) diodes as switching elements *the filter behaves as a lowloss (0.85 dB) single-band BPF with a passband around Abdul Quddious , Student Member, IEEE, 2.45 GHz Muhammad Ali Babar Abbasi , Member, Dynamically *The reconfigurable SIR filter can operate IEEE, Aqeela Saghir , Salman Arain , Student Reconfigurable as a dual-band BPF with two center Member, IEEE, Marco A. Antoniades , Senior SIR Filter Using frequencies at 1.6 and 2.45 GHz Member, IEEE, Alexis Polycarpou, Member, Rectenna and *The rectified output voltage is used as the IEEE, Photos Vryonides , Member, IEEE, and Active Booster enabling voltage for the dc-to-dc power Symeon Nikolaou, Member, IEEE booster * The filter switches from singleband to dual-band when a wireless input RF signal (> −13 dBm) is received by the RF triggered PMU antenna
*Presents a new rectenna using
beamwidth-enhanced antenna array for RF power harvesting applications. *By maximizing the power transmission A New efficiency between the 1×4 antenna array Rectenna and two auxiliary antennas, the optimal Using excitation distribution which leads to an Beamwidth- enhanced beamwidth can be determined. Enhanced * A high-efficiency rectifier is designed to Hucheng Sun, Member, IEEE and Wen Geyi, Member, IEEE Antenna Array convert the harvested RF power into DC for RF Power power and is then combined with the 1×4 Harvesting antenna array to form the proposed Applications beamwidth-enhanced rectenna * The rectenna’s efficiency is more than 50% when the wave incident angle is between –38 to 35 degree at the H-plane under the power density of 1276 W/cm2 Year Information about paper
2018 Antennas and Microwaves,IEEE
IEEE TRANSACTIONS ON ANTENNAS
2013 AND PROPAGATION,JULY2013
IEEE TRANSACTIONS ON 2019 MICROWAVE THEORY AND TECHNIQUES IEEE TRANSACTIONS ON 2019 MICROWAVE THEORY AND TECHNIQUES