Professional Documents
Culture Documents
6 CORPORATE PARKWAY
GOOSE CREEK , SC . 29445 STYLE NUMBER: BLFF8801IB
www . quoizel . com
PREPARATION
● Before beginning installation of product, make sure all parts are present. Compare parts with package contents
list and diagram above. If any part is missing or damaged, do not attempt to assemble, install or operate the
product. Contact customer service for replacement part.
● Estimated Assembly Time: 20 - 30 minutes
● Tool Required for Assembly (not included): Flathead screwdriver, Phillips screwdriver, Pliers, Electrical tape,
Wire cutter, Safety glasses and (1) 60W B10 candelabra base bulb .
● Helpful Tools (not included): Wire strippers.
1 OF 3
INSTALLATION INSTRUCTIONS STYLE NUMBER: BLFF8801IB
STEP 1:
a. Screw the Mounting Screws into the Crossbar, place Mounting Screw
Crossbar
the Lock Washers over the Mounting Screws and
thread the Hex Nuts onto the Mounting Screws as Hex Nut
shown. Secure the position of the Mounting Screws by
tightening the Hex Nuts against the Crossbar.
b. Secure the Crossbar to the Outlet Box with Outlet Box
Screws.
Lock Washer
Outlet Box
Outlet Box Screw
STEP 2:
Use Wire Connectors (not supplied) to connect the
WHITE OR RIBBED WHITE OR RIBBED
wires.
a. Connect the House Ground Wire to the Fixture Ground FROM HOUSE FROM FIXTURE
Wire.
b. Connect the House White (or Ribbed) Wire to the
Fixture Supply Wire (Black or Smooth Side). BLACK (OR RED) WIRE BLACK OR SMOOTH
c. Connect the House Black (or Red) Wire to the Fixture FROM FIXTURE
FROM HOUSE
Supply Wire (Black or Smooth Side).
d. Wrap each connection with approved electrical tape
and carefully stuff all of the connected wires into the GROUND WIRE GROUND WIRE
Outlet Box.
FROM HOUSE FROM FIXTURE
STEP 3:
a. Place the Backplate over the Mounting Screws and
secure with Mounting Balls. Hand-tighten until snug.
Backplate
Mounting Screw
Mounting
Ball
2 OF 3
INSTALLATION INSTRUCTIONS STYLE NUMBER: BLFF8801IB
STEP 4:
a. Screw one end of the Nipple with Hex Nuts into the
Bending Iron at the bottom of the Backplate. Using
pliers, thread on Hex Nut against the Bending Iron and Backplate
hand-tighten until snug.
b. Adjust the another Hex Nut on the Nipple to proper
location for the Cap and Finial.
c. Place the Cap over the end of the Nipple with Hex Nuts
and secure with the Finial. Hand-tighten until snug.
Bending Iron
Cap
Finial
STEP 5:
a. Place the Candle Cover over the Socket.
b. Locate the Shade over the Backplate. The bottom of
the Shade seats into the Cap. Line up the holes on the
side of the Shade and mounting holes on the Tabs at
the Backplate. Candle Cover
c. Thread Lock Screws into the mounting holes on the Backplate
Tabs and hand-tighten until snug to secure the Shade. Tab
Lock
Screw
Shade
Socket
Cap
STEP 6:
a. Install the correct Bulb referring to fixture markings and/or labels for maximum wattage.
Your installation is completed now. Restore electricity. Retain this sheet for future reference.
3 OF 3