Professional Documents
Culture Documents
1997jan Util and Strucl
1997jan Util and Strucl
MULTIPLE CHOICE:
9. One unit passenger elevator should be kept on 24-hour constant service to residential condominium of not more than:
A. 7 stories C. 6 stories
B. 5 stories D. 8 stories
10. A tray usually of perforated metal or wire mesh used for structural support of insulated wire cable
A. cable trench C. wire cable canal
B. cable carrier D. cable tray
11. Service drop of connection line shall have a minimum clearance above ground of not less than
A. 5.00 m C. 3.00 m
B. 4.00 m D. 2.80 m
12. The main feed line of an electrical circuit to which branch circuits are connected
A. power line C. distribution line
B. hotline D. main line
15. The criteria in the selection of an elevator other than interval and average waiting time handling capacity is
A. durability of the surfaced exposed to wear and tear C. door appearances
B. travel time D. ventilating system of the car
16. Any pipe, channel or trench by means of which waste liquid is carried away
A. drain C. spill way
B. pass-through channel D. waste water outlet
18. Poles and transformer support shall be located from the road right-of-way or property line with a distance of not more
than
A. 500 mm C. 600 mm
B. 800 mm D. 60 mm
21. A National Building Code ruling on new building expecting electric load demand of 200 kVa or more shall be provided
with
A. stand-by generator C. overload control device
B. transformer vault D. safety capacitor
26. An iron box places at the end of a conduit system where, electrical wire are joined to one another or to the fixtures:
A. pull-out box C. outlet box
B. cut-out box D. power box
29. Type of lighting that deals with lighting in relatively large areas is called
A. comprehensive lighting C. task lighting
B. area lighting D. general lighting
30. A covered trench to dispose the final discharge from septic vault by absorption into the ground
A. grease trap canal C. discharge distribution trench
B. absorption trench D. none of these
31. The quality of drinking water from meteoric surface of underground sources shall conform to the criteria set by
A. Mineral Water Distribution Association C. National Pollution Control Commission
B. DOH D. National Standard for Drinking Water
32. A passageway of insulated metal sheet for conveying air at low pressure
A. building canal C. channel through
B. air chute D. duct
34. A horizontal transport system that moves pedestrians mechanically and continuously during its operation
A. passengers conveyor C. horizontal escalator
B. pedestrian tractline D. moving walk
37. An underground structure for drainage into which the water from the root or floor will drain through sewer or street
drain
A. cistern C. cesspool
B. catch basin D. water trap
38. House sewer pipe connected from the building to the main sewer should have a slope of
A. 30% C. 20%
B. 2% D. 45%
39. The minimum diameter of discharge pipe and fitting for a bath tub
A. 1 3/4” C. 1 1/2”
B. 2” D. 2 1/2”
40. In cases of power failure or emergency to rescue the passenger, the elevator door could be opened through
A. safety shoe C. door lock switch
B. outside door latch D. safety gear
41. The process of heating, cooling, cleaning, humidifying or dehumidifying and air ducting air throughout various rooms to
achieve desired conditions
A. air conditioning C. atmospheric control
B. temperature control and management D. air control and management
JANUARY 1997 BOARD EXAMINATION 4
Part 2: Utilities Jan. 27, 1997 (08:00 am -– 12 noon)
42. The diameter from the crown to the weir in a pipe
A. maximum yielding tolerance
B. outside diameter
C. inside diameter
D. minimum threading of diameter
43. saf
44. fasdf
45. fsfsa
A. horse power
B. decibels
C. candle
D. ohms
50. fssdf
A. U.P. testing laboratory
B. Underwriter laboratory
C. Philippine Standard Council
D. National Plumbing Code