Professional Documents
Culture Documents
INSTALLATION
1. Women’s urinal fixture? a. 3 diameter
a. Bidet b. 1-1/2 diameter
b. Washdown c. 2 diameter
c. Flatback d. 1 diameter
d. Feminine stall urinal
9. Alternative to the conventional septic tank?
2. Which wall is best suited if soil pipe will run a. aerobic treatment system
through it? b. cistern
a. drywall c. STP
b. 6” CHB d. landfill
c. shear wall
d. remaining wall 10. A faucet fitted with nozzle curving
downward used as a draw-of trap?
3. What is the color coding of pipes for a. firehouse
potable water? b. bibcock
a. cyan c. lavatory faucet
b. green d. garden hose
c. blue
d. light blue 11. When water goes up through a vertical
pipe, it stops at a certain height. Why?
4. What is the standard water consumption a. gravity and friction overcomes the pressure
(gallon/ person/ day) used in a 2 storey and the water slowly stops.
residence? b. the pressure inside the pipe equates to the
a. 30-40 pressure outside the pipe causing the water
b. 40-60 to stop at that point where it appears.
c. 50-80 c. it’s own gravity weight counters its speed of
d. 90-120 going up.
d. all things stops.
5. What is installed in a fixture to alleviate the
effects of too much water pressure? 12. The minimum size of a swimming pool
a. water pressure regulator drain?
b. back splash a. 3” diameter
c. water filtration b. 4” diameter
d. regulator cup c. 2” diameter
d. 6” diameter
6. What can be discharge directly to sewer
system? 13. The minimum sized of a trap and waste
a. building sewer branch for a size of foot bath?
b. oil and grease a. 1 1/4 diameter
c. storm water b. 2 diameter
d. grey water c. 1 1/2 diameter
d. 1 diameter
7. Prevents water hammer?
a. water meter seal 14. Allowable slope of sanitary sewer?
b. float valve a. 1 ft of 1 meter
c. check valve b. 1/2 in of 1 meter
d. air chamber c. 1/4 of 1 meter
d. 1/4 of 1 ft
8. The minimum size trap and waste branch
for a bidet?
1
SANITATION, PLUMBING DESIGN &
INSTALLATION
15. What is used to shut off flow of water c. water pipe
during maintenance? d. AC ducts
a. check valve
b. angle valve 22. What is the typical slope of a waste pipe?
c. gate valve a. 1%
d. globe valve b. 2%
c. 3%
16. The minimum size of a trap and waste d. 4%
branch for a shower stall?
a. 2 diameter 23. One of the first steps in the selection of a
b. 3 diameter suitable water supply source is?
c. 1 1/2 diameter a. water (potability)
d. 1 diameter b. topography
c. budgetary cost
17. The part of a vent line which connects d. water (demand)
directly with an individual trap underneath of
behind the fixture and extends to the branch 24. Can you embed a 4” diameter pipe in a
or main pipe at any point higher that the 150 wall?
fixture trap? a. no
a. blow-pipe b. yes
b. VTR c. maybe
c. Back vent pipe d. sometimes
d. soil pipe
25. According to NBC, pipe support should be
18. How do you connect PPRC? every,
a. mechanical fastener a. 3 m
b. solvent b. 1.5 m
c. fusion welding c. 2 m
d. coupling d. 4 m
19. A toilet bowl in which the flushing water 26. In high rise buildings, why is there a need
enters through the rim and sipping action to resize water supply pipes?
ignited by a water jet draws the contents of a. because different fixtures have different
the bowl through the tramway? supply attached.
a. siphon jet b. to use up the difference in pressure from
b. siphon vortex the service to the supply fixture.
c. reverse trap c. pipes are like trees, main branch are bigger
d. washdown and becomes smaller at ends for carrying
wind loads and storms.
20. Which plumbing fixture does not have a d. pipes having bigger size have bigger
water-saving feature? pressure and reduce the size for distribution
a. lavatory with pop-up to fixture for lower pressure.
b. 1.5 gallon flush water closet
c. flow limiting feature
d. waterless urinal
27. Valve permitting a gas or liquid to flow in
21. What should not be permitted to cross a one direction?
beam? a. check valve
a. soil pipe b. globe valve
b. electrical wiring c. angle valve
2
SANITATION, PLUMBING DESIGN &
INSTALLATION
d. gate valve a. under the sidewalk on narrow road and
under the road on wide road
28. What is the minimum trap seal? b. underground drainage line should be on
a. 1.5” top of compacted soil
b. 2” c. it should be underneath the driveway
c. 2.5” d. none
d. 3”
36. Best location to put the soil pipes?
29. What is the color of pipes for steam? a. drywall
a. light blue b. 150 mm CHB wall
b. gray c. pipe chase
c. blue d. box-up with the column
d. white
37. This material is used in threaded pipe
30. A sewage treatment that includes the connections to prevent leakage.
exposure to air? a. polymer
a. aerator b. elastomeric gasket
b. air-dehumidification treatment system c. Teflon
c. exposed STP system d. structural polyester thread
d. SW treatment system
38. The minimum number of water closet unit
31. Fluoride as an addictive in water supply is required for the female population of an
a chemical for? elementary school?
a. purify a. 1 per 75
b. coagulant b. 1 per 25
c. disinfectant c. 1 per 50
d. dental d. 1 per 30
32. Where should you place soil-pipes for 39. Copper pipes are classified as what main
high-rise structures? pipe?
a. pipe chase a. galvanized iron
b. partitions b. ceramic
c. RC wall c. s/s
d. column d. PVC
33. Should not be used for a pipe chase? 40. Best for sanitary pipes?
a. chb a. uPVC
b. drywall b. PeX
c. shear wall c. PP
d. double wall d. G.I.
56. What is use for water treatment in a 62. What type of pipe is not recommended
swimming pool? for water line?
a. chloride a. copper
b. sodium b. lead
c. cyanide c. GI
d. hydrochlor d. iron
57. In a location where there is no provision 63. The prescribe color coding of piping under
for drainage line, what is the next best thing? refrigerating division of all pipes and fittings?
a. store waste in the tank and dispose in a. white
sanitary fill b. yellow
b. use drain tiles connected to open field c. gray
c. connects to the nearest creek d. black
d. any of the above
64. The quality of galvanized iron pipes are
58. A pipe fitting to join two straight lengths rated by?
of pipe? a. class
a. coupling b. schedule
b. nipple c. thickness
c. tee d. gauge
d. elbow
65. Standard water pressure from NAWASA?
59. Minimum size of trap of shower drain? a. 60 psi
a. 3 b. 120 psi
b. 4 c. 30 psi
c. 2 d. 40 psi
d. 1 1/2