Professional Documents
Culture Documents
3. What is the vertical distance between the dip and crown weir of
the trap?
a. Trap arm
b. Trap seal
c. Trap adapter
d. Trap weir
4. What is that vent pipe system in which liquid waste flow through?
a. Dry vent
b. Wet vent
c. Back vent
d. Stack vent
11. Materials usually used for hot and cold water supply
systems are not made of ____.
a. Copper
b. Brass
c. Asbestos cement
d. Wrought iron
15. How many urinals are required for assembly place for public
use with 350 males?
a. 1
b. 2
c. 3
d. 4
19. This refers to the water supply pipe between the fixture
supply pipe and the water distributing pipe.
a. Fixture branch
b. Fixture supply
c. Building supply pipe
d. Service pipe
28. For assembly places for public use, how many water closets
are required if the capacity is 180 males?
a. 1
b. 2
c. 3
d. 4
43. The water that comes from rain that is absorbed into the
ground and is slowly filtered through the different layers of the
ground and into the groundwater reservoirs which are also known
as ______.
a. Wells
b. Aquifers
c. Water table
d. Runoff
For No. 58-60, identify the following based on the type of trap seal
loss in Figure 1.
65. Before water from any source will be adopted for domestic
water supply, what kind of examinations are needed?
a. Infiltration and sedimentation
b. Aeration and bacteriological
c. Dilution and chemical
d. Chemical and bacteriological
66. Class ___ fire is coded for combustible metals and alloys.
a. A
b. B
c. C
d. D
For numbers 67-69, use figure 2 to identify the parts of the given
plumbing ventilation.
67. Identify A.
a. Back vent
b. Main vent
c. Individual Vent
d. Stack Vent
68. Identify C.
a. Back Vent
b. Main Vent
c. Individual Vent
d. Stack Vent
69. Identify D.
a. Fixture branch
b. Soil stack
c. Soil branch
d. Fixture drain
a. I, II and IV
b. I, III and IV
c. I, II and III
d. II, III and IV
74. Which sources of water supply was not used in older days?
a. Rain
b. Spring and wells
c. Creeks and rivers
d. Centralized treatment reservoirs
79. What is the water that comes from rain and snow that runs
off into rivers and lakes?
a. Surface
b. Drinking
c. Potable
d. Ground
80. The design and construction and operation of deep wells for
the abstraction of ground water, shall be subject to the
provisions of the water code of the Philippines. What PD is this
called?
a. PD 1067
b. PD 1062
c. PD 5489
d. PD 6351
89. A hose fitting with clapper valves for combining the flow
from two or more lines of hose into a single stream. The inlet
fitting of a fire standpipe located above ground level.
a. Siamese Connection
b. Water supply pipe
c. Combination standpipe
d. Dry standpipe
94. What is a G.I or PPR fitting which is used when a pipe has
already been installed but dismantling is difficult?
a. Flange
b. Coupling
c. Reducer
d. Union
For numbers 96-98, refer to Figure 3 for the types of globe valve.
96. Identify i.
a. Conventional Type
b. Composition Type
c. Plug Type
d. Lift Type
100. How many gallons of water for the water closet flushing
requirement?
a. 1-2 gallons
b. 2-2.5 gallons
c. 3-5 gallons
d. 10-15 gallons
Figure I
58.
.
59.
60.
Figure 1
A
C
Figure 2
Table 1
i ii
iii
Figure 3