Professional Documents
Culture Documents
Bluetooth Bee Manual Xbee
Bluetooth Bee Manual Xbee
2
User Manual
Product Overview
The Tinyos Bluetooth Bee is a Bluetooth wireless module Based on CSR BC417143
Bluetooth chipset. It has compact size and the pinout is compatible with XBEE which is
suitable for all kinds of microcontroller systems who have 3.3V power out, the module can
use the AT commands to set baud rate.
The Bluetooth Bee module comes with an on-board antenna, the antenna provides better
signal quality. It acts like a transparent serial port, which works with a variety of Bluetooth
adapter and Bluetooth phone.
The module has been tested with all the Bluetooth adapter on the market matching to use
(with the Bluetooth, including laptops and mobile phones).
Pin out
LED State:
:
LINK: Indicate module state. when power on blinking .
www.tinyosshop.com
STATE: When module linked with other device LED on.
Features
AT Command
The current version of the module only supports AT commands used to set the baud rate.
The default baud rate for this module's AT mode is 38400bps. For regular use, the default
baud rate is 9600.
Entering AT mode
• Using Arduino Serial Terminal and USB Xbee converter. You can download
Arduino IDE Here
• Place the module into AT Mode while powered off. Apply power to it and open the
corresponding com port in Arduino IDE's serial terminal. Set the Baud rate to
38400 and the setting next to that to "both NL & CR". You should now be able to
send AT commands to the Bluetooth bee.
www.tinyosshop.com
Test Command
• Transmit:AT
• Return:OK
• Transmit:AT+UART?
• Return:+UART:9600,0,0
• Return:OK
• Transmit:AT+UART=19200,0,0
• Return:OK
AT+UART=<Param1>,<Param2>,<Param3>
Param1:Baud rate
• 4800
• 9600
• 19200
• 38400
• 57600
• 115200
• 230400
• 460800
• 921600
• 1382400
• 0-1bit
• 1-2bit
www.tinyosshop.com
Param2: Parity bit
• 0-None
• 1-Odd
• 2-Even
Bluetooth Bee default Name is ‘BluetoothBee’. You can also change this name by yourself
to identify it when you use multiple Bluetooth Bee modules.
• Transmit:AT+NAME=<Param>
• Return:OK
• Transmit:AT+PSWD=<Param>
• Return:OK
Setting as Master/Slave
• Transmit:AT+ROLE=1
• Return:OK
AT+ROLE=<Param1>
Param1:
• 0--Slave
• 1--Master
• 2--Slave-Loop
Searching new bluetooth device. You will find a new bluetooth device which named
BluetoothBee
www.tinyosshop.com
Turn on AT switch and then power on the module to entering AT mode and send AT
command.
AT Command:
AT+CMODE=1
AT+ROLE=1
Turn off Master module AT switch and Power two Bluetooth Bees.They will automatic
binding and in transparent data mode.STATE LED will light on.
All 2 Bluetooth Bees stack on Xbee adapter and connected with PC. You will find 2 Com
ports in Device Manager.
www.tinyosshop.com
Bluetooth Bee STATE LED light on. This indicated that two modules Binding complete.