Professional Documents
Culture Documents
Mmo=.82M
Term Definition
What's the definition of Va? Va is Maneuvering Speed and is the
avoided.
Term Definition
What is the speed range for Va? Va= 260 kias at sea level
Term Definition
Flap Placard Speed (Vfe) 1, 2, 5 - 250 kias
10 - 210 kias
15 - 200 kias
25 - 190 kias
30 - 175 kias
40 -162 kias
Term Definition
Verify the Flap Limit (IAS) on the placard under the landing gear lever
_________________ during normal operations.
Term Definition
Landing Gear Placard Speed Retract...235 kias
Extended...320 kias/.82M
Term Definition
Minimum Flight Crew requirement A Captain and a First Officer
Term Definition
Max Cabin Differential Pressure (Relief Valve) 9.1 psi
Term Definition
Max Allowable Cabin Pressure Differential .125
for psi (236 feet below airport pressure altitude)
T/O and Landing
Term Definition
With Engine Bleeds on, do NOT operate packs in Takeoff, Approach or Landing
High for ____, _____or _____.
Term Definition
Icing conditions exist when_________. the OAT on the gnd or TAT inflt is 10C or less,
and visible moisture in any form is present. Also
when on the gnd with temp 10C or less where
surface snow, ice, flooded or slush may be
ingested by the engines or freeze on the engines or
nacelles
Term Definition
Engine Anti-ice must be on ________. during all gnd and flt ops when icing conditions
exist or are anticipated, except during climb and
cruise when the temp is below -40C SAT (Prog pg
2)
Term Definition
Do not use ____ ____ ____ as a substitute for wing anti-ice system
ground de-icing/anti-icing and inspection
procedures.
Term Definition
Don't operate wing anti-ice when the OAT is above 10C
_____________.
Term Definition
Takeoff is not permitted if there is cold soaked
-it exceeds 3mm on the lower surfaces
fuel frost on the lower or upper wing tank
surface, as follows: - on the upper surface and
Term Definition
Do not engage the autopilot after takeoff below 400 ft. AGL
_______.
Term Definition
For single channel operation during approach, 50 ft. AGL
the autopilot shall not remain engaged below
_____.
Term Definition
True or False.... True
Term Definition
Max allowable wind speeds when landing weather
Headwind........25 knots
minima are predicated on autoland operations:
Tailwind...........15 knots
Headwind.........____
Crosswind........20 knots
Tailwind.......____
Crosswind......____
Term Definition
Maximum and Minimum Glideslope Angles for Max-3.25 deg
Auto Landing
Min-2.5 deg
Term Definition
What flap settings may be used for Auto Flaps 30 or 40 (and both engines must be
Landing? operating)
Term Definition
Holding in icing conditions with flaps extended is Prohibited
________.
Term Definition
Don't use which radio for ATC voice comm with VHF-3
ACARS operational?
Term Definition
What must be done in order to use Digital ATISYou must VERIFY that the numeric values
and/or W&B from the ACARS? match the alpha values.
Term Definition
Installation of handle covers on the overwing exits
Prior to departure whenever passengers are
must be verified when? carried.
Term Definition
The flight deck door access system must be Once each flight day
verified operational how often?
Term Definition
Photoluminescent Floor Emergency Lighting Charged
must be ___________ in accordance with
approved procedure.
Term Definition
On the ground, limit one engine-driven generator 75
to a maximum of ____KVa
Term Definition
Engine Limit Display Markings Max/Min---------red line
Term Definition
Engine RPM N1
Term Definition
Engine EGT limits for Takeoff, Max Continuous
Takeoff...................950C 5 min limit
and Starting
Max Continuous......925C
Starting...................725C
Term Definition
Not a limitation...but nice to know: N1 and N2 all the time
Which of the following does the EEC monitor? EGT only during engine start
N1
N2
EGT
Term Definition
When EEC's are used in ALTN mode:
derate thrust for T/O is not allowed
derate thrust for T/O is ______ both EEC's must be in alternate
____ EEC's must be in alternate do not use the FMC T/O N1 or Vspeed
_____ the FMC T/O N1 or Vspeed value use of autothrottle for T/O is prohibited
use of autothrottle for T/O is _____
Term Definition
Engine Oil System Min Press- 13psi
Term Definition
When must Engine Ignition be on and whenMust
is be on for T/O, Landing, in Heavy Rain and
that taken care of automatically? during Anti-ice operation.
Term Definition
When can you use Reverse Thrust? Ground operations only
Term Definition
Full takeoff thrust (26K) must be checked periodically
__________.
Term Definition
APU (Max altitudes)
Bleed & Electrical......10,000 feet
Bleed & Electrical Bleed only.....................17,000 feet
Bleed only Electrical only..............41,000 feet
Electrical only
Term Definition
APU Bleed Valve must be closed when?
ground air connected and isolation valve
open
Eng. No. 1 Bleed Air Valve open
Isolation and Eng. No. 2 Bleed Air Valves
open
Term Definition
Max flap extension altitude 20,000 feet
Term Definition
Flight Controls rapid and large alternating
Term Definition
Do not deploy speed brakes inflight below 1000 feet AGL
_________.
Term Definition
Inflight, do not extend the speed brake lever the Flight Detent
beyond _________.
Term Definition
Standby Altimeter ___________ altimeter does not meet
accuracy requirements of RVSM airspace.
Term Definition
Max allowable on-the-ground altitude display Between Capt & FO ...... 50 feet
differences:
Between each altimeter and field elevation...... 75
feet
Term Definition
Max allowable inflight difference between Capt & 200 feet
FO altitude displays for RVSM ops is:
Term Definition
Air Data Inertial Reference Unit 78 deg 15 min
Term Definition
Do not operate the Weather Radar where?in a hangar or within 50 feet of any personnel or
fuel spill
Term Definition
Do not use terrain display for ______. navigation
Term Definition
The use of look-ahead terrain alerting and display
Within 15 nm of takeoff, approach or landing at
functions are prohibited where? an airport not in the GPWS database.
Term Definition
Fuel System No. 1 or No. 2 tanks.......... 9,144 lbs each
Center tank...........______
Term Definition
Fuel Loading equally
Term Definition
Fuel Loading must be scheduled to be full
Term Definition
True or False False
The following fuels are allowed for use in the 737- JP-4 and Jet B are prohibited
800:
Jet A
Jet B
JP-4
Term Definition
Maximum Tank Fuel Temperature 49C
Term Definition
Minimum Inflight Tank Fuel Temperature3C
is above the freezing point of the fuel being used
____________. or -43, whichever is higher.
Term Definition
Fuel imbalance must not exceed ______ for taxi, 1000 lbs.
T/O, flight or landing.
Term Definition
Describe the Fuel Usage requirements. With no fuel in the center tank, use main tank to
engine (main tank pumps-on, center tank pumps-
off, crossfeed-closed)
Term Definition
The Fuel Crossfeed Valve is opened for?
Minimum fuel operation
to correct a fuel imbalance
Term Definition
Intentional dry running of a center tank fuel prohibited
pump (low pressure light illuminated) is
_________.
Term Definition
Name three situations where the Center Tank
Fuel Pumps should be turned off on the ground. No personnel are available on the flight
deck to monitor the low pressure lights
Center tank quantity not greater than
1000 lbs. (unless defueling or transferring)
when the low pressure lights illuminate
(both off if quantity zero)
Term Definition
True or False... False
For executing a short field landing, hold the Do not apply brakes until after touchdown.
brakes prior to touchdown.
Term Definition
If operating with secondary airframe or engine the MEL/CDL manual
parts missing, the airplane must be operated in
accordance with ________.
Term Definition
Max Crosswind Dry..................................................29 knots
Flooded.........................................___
Term Definition
Max Crosswind for Ice or Snow Braking Action
Term Definition
Max Crosswind 2mm or less..............................15 knots
2mm or less..............................____
3-12 mm....................................____
Term Definition
True or False... True
Term Definition
If something other than a JCAB Braking Action Use the chart on page 1-4-(2)
is reported (friction coefficient, US Military, FAA
or ICAO), how do we convert to JCAB?
Term Definition
True or False... False. Operations with BA of Very Poor are
prohibited.
Operations when Braking Action is reported as
Very Poor require a Max Crosswind of less than
10 knots.
Term Definition
Precipitation on Runway Slush.........................at or above 13 mm
Wet Snow................________
Dry Snow..................________
Term Definition
Maximum demonstrated crosswind: Non W.............36 knots
With W...........____
Term Definition
If Braking Action divides the runway into three the worst of the three whether it's T/O or
sections, which one is applied for T/O and Landing
Landing?