Professional Documents
Culture Documents
Application Diagram
Cross-Connection Diagram
NOTE
In this configuring process, a TN54NS3 board in compatible mode is used as an example in Figure
Procedure
Step 1 Configure attributes of client-side ports on the TN52TQX board of station A.
1. In the NE Explorer, select the TN52TQX board that you want to configure, and then
choose Configuration > WDM Interface from the Function Tree.
2. Click By Board/Port (Channel), and select Channel from the drop-down list.
3. Select the Basic Attributes tab.
4. Select the ClientLP port, the service type that needs to be set, and then double-click the
corresponding parameter domain to set the following parameters.
– Service Type: 10GE LAN
– Port Mapping: Bit Transparent Mapping (11.1G)
NOTE
5
:When the service type is 10GE LAN, the service mapping path can be Bit Transparent
Mapping (11.1G) or MAC Transparent Mapping (10.7 G) . Users can select the service
mapping path based on the service transmission requirements.
When Port Mapping is set to Bit Transparent Mapping (11.1G), the service cross-connect
granularity is ODU2e. When Port Mapping is set to MAC Transparent Mapping (10.7 G) , the
service cross-connect granularity is ODU2.
6. On the Advanced Attributes tab, select the ODU2 port and ODU3 port and double-click
the Line Rate parameter and set to Speedup Mode.
– When Port Mapping of the ClientLP port on the TQX board is set to Bit
Transparent Mapping (11.1 G), Line Rate of the corresponding ODU2 port of the
TN54NS3 board must be set to Speedup Mode. Line Rate of the ODU3 port must
be set to Speedup Mode.
– When Port Mapping of the ClientLP port on the TQX board is set to MAC
Transparent Mapping (10.7 G) , Line Rate of the corresponding ODU2 port of the
TN54NS3 board must be set to Standard Mode. Line Rate of the ODU3 port can be
set to Standard Mode or Speedup Mode.
Port Mapping and Line Rate of the boards that services pass must be consistent;
otherwise, service interruption occurs.