Professional Documents
Culture Documents
3. INTRODUCTION OF DANGER
Procedure note : Report the spill happened according to system and procedure
decided. If the spill could be enter the aqueduct or river,
please report to authority officer as soon as possible.
Leakage and Spill Procedure : Absorb the spill by saw-dust, clay, and another fire resistant
material. Clean up and discard to the location that have been
decided.
Prevention on Environment : Prevent the spill entering the gutter, waste canal, and into the
soil.
Prevention on Human being : see section 8.
This product contains petroleum base oil which may be refined processes including severe
solvent extraction, hydrocracking and hydrotreating. These oils have not been listed in the
U.S National Toxicology Program (NTP) Annual Report nor have they been classified by
the International Agency for Research on Cancer (IARC) as carcinogenic or probably
carcinogenic to humans.
Based on U.S. Superfund Amendment and Reauthorization Act (SARA) this product doesn’t
contain EXTREMELY HAZARDOUS more than 1%.
SARA (311/312) REPORTABLE HAZARD CATEGORIES
To the best our knowledge, the information provided in this MSDS document is correct.
Access in this information is being provided via the internet so that it can be made available
to us many potential users as possible. We do not assume any liability for consequences of
the use of this information since it may be applied under conditions beyond our control or
knowledge. Also, it is possible that additional data could be made available after this MSDS
was issued. Certain hazard are described herein; however these may not be the only hazard
that exist. All materials may present unknown hazard should be used with eruption.
Customers are encouraged to review this information. Follow precautions, and comply with
all applicable law regulation regarding the used and disposal of this product. For specific
technical data or active concerning this product as supplied in your country please contact
your local sales representative. The final determination of the suitability of any materials is
the sole responsibility of the user.