Professional Documents
Culture Documents
BEGINNER’S SOLUTION
For forming the White Cross, first move the edge piece around on instinct in such a way that it gets
placed directly below where it is supposed to be inserted. Then move the side 180 degrees & place the
piece in its right place. If the edge piece is in the right slot but inverted then use the following algorithm:
R’ U F’ U’
For that move the corner piece around on instinct to the bottom layer into the place directly below where
it needs to be lodged. Then use the following algorithm and keep repeating this step till you get it right:
R’ D’ R D
If edge piece is in middle layer, use any one of the above equations and the edge piece will get lodged in
the top layer. Then move it around as explained above and repeat the whole process.
Use the following algorithm & convert the cube into this state.
R U R’ U R U2 R’
Then apply the algorithm once again to achieve the desired result.
For final alignment of the pieces, use the algorithm again and the final result would be;
A Completed CUBE!!!