Professional Documents
Culture Documents
Screw Type Positioner User Manual (EN) Rev 01
Screw Type Positioner User Manual (EN) Rev 01
Hex nut
Washer
Rubber Bush
Washer
Hex. Bolt
2
Step 1
Drill a hole on the formwork for installing the positioner. See the
hole sizes as per model of GROUTEC couplers
GROUTEC S Drill Ø GROUTEC L Drill Ø
S12 7/6” or 11 mm L12 9/16” or 14 mm
S16 9/16” or 14 mm L16 9/16” or 14 mm
S20 9/16” or 14 mm L20 11/16” or 17 mm
S22 9/16” or 14 mm L22 11/16” or 17 mm
S25 9/16” or 14 mm L25 11/16” or 17 mm
S28 11/16” or 17 mm L28 11/16” or 17 mm
S32 11/16” or 17 mm L32 11/16” or 17 mm
S36 11/16” or 17 mm L36 11/16” or 17 mm
S40 11/16” or 17 mm L40 11/16” or 17 mm
Step 2
Install the positioner through the hole of formwork.
Formwork
Step 3
Assembly the washer and Hex. nut to fix the set of positioner.
Lightly tighten the Hex. nut.
Step 4
Step 6
Hold the screw end with the wrench and tighten the Hex. nut
with another wrench for expand the rubber bush. Make sure
the GROUTEC coupler is properly and firmly secured in the
formwork.
Tighten Hex. nut
Step 8
Step 10
Plastic cap