Professional Documents
Culture Documents
CONSTRIP 3
Mould Release Agent
1. IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND COMPANY
www.cormix.com
2. COMPOSITION/INFORMATION ON INGREDIENTS
3. HAZARDS IDENTIFICATION
These products are not known nor expected to be hazardous, but as with all chemical products, exercise caution in
handling and using this material.
1 OF 5
Material Safety Data Sheet: CONSTRIP 3
Eye Contact : Flush with large amounts of water, lifting the upper and lower lids occasionally
Skin Contact : Wash skin thoroughly with water and soap
Ingestion : Not applicable
Inhalation : Not applicable
Fire Hazard :
Product is water based and in the wet form it is a low fire hazard. The dried polymer is combustible. Decomposition
products could be toxic.
Extinguishing media :
Water, alcohol-resistant foam, powder, CO2 , sand …all extinguishing media are suitable.
Protective clothing and self-contained breathing equipment should be available for firemen.
Eye contact: Flush without delay with clean water whilst holding the eyelid open. Take care not to wash product
from one eye to the other. Use plenty of water for at least 10 minutes. If symptoms persist obtain medical assistance
without delay.
ISkin contact: Prolonged or frequent contact with the product can cause irritation. Wash all splashes
immediately from the skin with soap and clean water, if any other skin symptoms occur obtain medical assistance.
Inhalation: Remove the casualty from the area of exposure. Obtain medical assistance if symptoms persist.
Further information: Cormix International Ltd. products are generally safe to use provided certain precautions
normally taken when handling chemicals are observed. Unless specified products should not come into contact with
drinking water, foodstuffs or food equipment and measures should be taken to prevent skin contact, since people
with particularly sensitive skin may be affected. The use of barrier creams, goggles and industrial gloves is
recommended. The skin should be cleansed at the end of each working period using a suitable industrial cleanser
or warm water and soap, the use of solvents to clean the skin is not recommended. Adequate ventilation of the
working area is recommended. Take careful note of all safety information on data sheets and labels.
2 OF 5
Material Safety Data Sheet: CONSTRIP 3
Handling :
Good industrial and personal hygiene practice should be followed. Not Hazardous, however, all industrial chemicals
products should be handled with care to avoid over exposure.
Keep containers well closed and in well ventilated area in accordance with the petroleum requlations.
Appearance : Liquid
Colour : White liquid
Odor : oil
Boiling point : no data
Specific gravity at 25oC : 0.98 - 1.05 kg/ltr
Vapor pressure : not applicable
Flash point : 160 o C
Flammability : not applicable
Auto ignition temp. : not applicable
Explosive/ oxidizing : not applicable
pH Value at 25oC : N/A
Solubility : Very low
Hazardous polymerization : Will not occur
3 OF 5
Material Safety Data Sheet: CONSTRIP 3
Can cause burns and/or serious eye damage (B) risk of sensitization which may lead to allergic dermatitis.
The Product is immiscible with water but there is only a slow environmental breakdown of the Product, but
seemingly on tendency for bioaccumulation.
Water for sewage treatment that has been contaminated with small quantities of the product will not affect the
biomass. Absorption of the material onto the sludge will occur with subsequent elimination from the waste stream.
Absorb the chemical spillages with dry sand. place in polythene bags for disposal to an authorized waste site. wash
the area with strong industrial detergent and water.
GGVSee/IMDG-Code : RID/ADR:
GGVE/GGVS : ICAO/IATA-DGR:
UN-NR : ADNR
The Product is not classified as dangerous for transport.
The Product has no hazard classification within the meaning of EC Directive 88/379/EEC.
There is no labeling required.
The Product has no EC-number and it is not listed in EINECS.
4 OF 5
Material Safety Data Sheet: CONSTRIP 3
16 OTHER INFORMATION
Disclaimer
For general safety and handling information please refer to Cormix International Ltd. The information shown is
based on our experience to date and is true to the best of our knowledge. Any recommendations or suggestions
made are without any guarantee. No responsibility is accepted that the information herein is sufficient or correct in
all cases.
5 OF 5