Professional Documents
Culture Documents
Instruction Manual
o
.c
High-Definition Link for Volkswagen Golf(MK7)
ns
u tio
ol
r-s
ca
Device related
m
• You should check the names and colors of each wires exactly, before you connect the wires.
ex) CAN HIGH: White wires / CAN LOW: Blue wires
o
• The ‘POWER / CAN Cable’ should always be connected last and be disconnected first.
.c
• The 'Mode Switch' is an optional part to change modes forcibly without CAN-BUS.
Generally, the CAN-BUS wires are connected for changing modes by original buttons.
ns
• When the reverse gear is not detected by CAN-BUS,
the 'REVERSE 12V IN wire’ should be spliced with 12V power of reverse light.
tio
HDMI device-related
• HDMI mode accepts general-screen resolution of HDMI devices.
If screen size of HDMI does not fit on the monitor, should adjust screen size & position in 'settings mode'.
•
u
Generally, '5V 1A Power output(5V USB POWER)' is a standard voltage for charging smartphone.
ol
If you need higher voltage than 5V, you should add a separate power supply.
r-s
Navigation(GPS) box-related
• When you connect the power wires(B+, ACC) to the navigation(GPS) box,
the ‘NAVI 12V OUT' wire supported by the device should be spliced with an ACC wire of navigation box.
ca
• After installation is done, select an applicable navigation(GPS) box model in the 'Navigation model selection
menu' of setting mode.
• The navigation box should be powered off before unplugging the HDMI cable.
www.car-solutions.com support@car-solutions.com
Dimension Width: 142 mm
Height: 22 mm
o m
.c
Length: 91 mm
ns
tio
ⓐ ⓑ ⓒ ⓓ ⓔ
Exterior
ⓐ DIP SWITCH
u ⓑ AV IN / OUT
ol ⓒ TOUCH IN
ⓓ MODE
r-s
ⓔ POWER / CAN
ⓕ HDMI IN
ⓖ 5V USB POWER
ca
ⓗ NAVI IN
ⓘ UART I/F
ⓙ LVDS OUT
www.car-solutions.com support@car-solutions.com
ⓕ ⓖ ⓗ ⓘ ⓙ
Components
o m
.c
ns
Power / CAN Cable LVDS Cable LVDS PCB HDMI Cable AV IN / OUT Cable 5-pin Micro USB Cable
(For LVDS)
tio
Optional Parts
u
ol
r-s
ca
www.car-solutions.com support@car-solutions.com
1 - 3 - 8 -
12-pin Connector of OEM Monitor
*Please refer to next page.
7 - 9 - 11 -
Full Installation Diagram OEM MON CAN HIGH(Orange/Purple) / No.3 /*2015 Polo(Orange/White)
OEM MON CAN LOW(Orange/Brown) / No.9
m
MON CAN IN L(Blue)
o
14
.c
1 6
External Rear View 12V Power Output & GND Output(RV-CAM Power)
Camera 4 8 12 7 12
Reverse Signal Detection(optional)
ns
DIP S/W Setting
tio
Navigation Box GND(Black)
Pin # 15 = GND(Brown)
BAT+(Yellow)
Pin # 16 = B+ POWER(Red)
PAS CAN H(White)
Pin # 6 = PAS CAN HIGH(Orange / Purple)
u
PAS CAN L(Blue)
Audio Output Pin # 12 = PAS CAN LOW(Orange/Brown)
*Yellow dotted lines
*The wires color might be different depends on models.
Auxiliary(AUX)
ol you have to splice the CAN wires with twisted wires
each pins exactly.
Input of the car
r-s
OEM Head Unit
HDMI HDMI
OEM Monitor
LVDS IN / OUT Connection
(OEM LVDS Cable)
LVDS
HDMI
IN / OUT
(Provided LVDS Cable)
PCB
AV-Input(AV2)
AV device
www.car-solutions.com support@car-solutions.com
(ex: DTV Box, Divx)
HDMI Device Navigation Box
MON CAN Wires IN / OUT Connection Diagram
m
POWER / CAN MODE TOUCH-IN AV IN / OUT DIP SWITCH
o
.c
OEM Monitor
ns
1 2 3 4 5 6 7 8 9 10
① Remove a harness from 12-pin connector. ② No.3 Pin: OEM CAN H / No.9 Pin: OEM CAN L
tio
1 - 3 - 5 -
u
7 - 9 - 11 -
ol
PAS CAN H
PAS CAN L
GROUND
GROUND
BAT +
m
HDMI IN 5V USB NAVI IN UART I/F LVDS OUT HDMI IN 5V USB NAVI IN UART I/F LVDS OUT
POWER POWER
o
.c
ns
HDMI USB HDMI USB
u tio
HDMI
HDMI (5V-1A Power output for HDMI Device)
(Male)
(5V-1A Power output for HDMI Device)
(Female)
ol
(HDMI Extender) (HDMI Cable)
‘Stick Type’ HDMI Devices ‘Dongle & Adapter’ Type HDMI Devices
r-s
ca
www.car-solutions.com support@car-solutions.com
Compatibility Navigation(GPS) box Navigation Connection Diagram(Type B)
Navigation(GPS) Box
Dip S/W
m
Model Country Required Parts HDMI IN 5V USB NAVI IN UART I/F LVDS OUT
(Navigation)
POWER
ON
o
↑
South 1 2 3 4
.c
Korea
KAP OFF(↓): 1, 2, 3 HDMI Cable
TOUCH IN
ns
KG-W14H ON(↑) : 4 (Male to Male) HDMI
tio
with 'Digital video output'.
u
ol (Touch Cable of KG-W14H)
r-s
HDMI
ca
KAP – KG-W14H
www.car-solutions.com support@car-solutions.com
LVDS Connection Diagram
LVDS Connection
m
HDMI IN 5V USB NAVI IN UART I/F LVDS OUT
POWER
OEM Monitor
o
.c
ns
HDMI
u tio
(Provided LVDS Cable)
• 'Genuine(OEM) LVDS Connector' should be connected
ol
to ‘LVDS IN / OUT PCB'.
• ‘Provided LVDS Connector' should be connected to the Multimedia System - OEM Head Unit
OEM monitor instead to the genuine connector.
r-s
LCD
Cable
(OEM LVDS Cable)
LVDS
HDMI
IN / OUT
ca
PCB
www.car-solutions.com support@car-solutions.com
Body Connector specifications
POWER / CAN MODE TOUCH-IN AV IN / OUT DIP SWITCH
m
(NO. 1, 2 Pins)
o
.c
1 2 3 4 5 6 7 8 9 10 11
ns
1 2 3 4 5 6 7 8 9 10 1 2 1 2 3 4 1 2 3 4 12 13 14 15 16 17 18 19 20 21 22
REAR CAMERA
NAVI AUD IN R
NAVI AUD IN L
AUDIO OUT R
MON CAN OUT H
AUDIO OUT L
MON CAN IN H
MON CAN IN L
AV2 IN R
AV2 IN V
AV2 IN L
AV1 IN V
NAVI 12V OUT
tio
REVERSE 12V IN
PAS CAN H
PAS CAN L
GROUND
GROUND
REAR 12V
GROUND
BAT +
IR OUT
Length: 40 cm
8 MON CAN IN LOW Touch Cable 8 AV1 VIDEO INPUT 19 GND(AV1 VIDEO IN)
9 MON CAN OUT HIGH Mode Switch (Connector Type) 9 AV2 VIDEO INPUT 20 GND(AV2 VIDEO IN)
10 MON CAN OUT LOW 10 AV2 AUDIO INPUT R 21 GND(AV2 AUDIO IN R)
11 AV2 AUDIO INPUT L 22 GND(AV2 AUDIO IN L)
•
www.car-solutions.com
The colors of each wires can be changed under manufacturer’s circumstance.
support@car-solutions.com
Car Compatibility Chart
Production
Car Models Specific Models
m
Year
o
Polo 2014 - MK5
.c
ns
The device is used in combination
with Volkswagen INFOTAINMENT
System.
tio
- VW Golf Discover Pro(8-inch)
- VW Golf Discover Media(5.8-inch)
- VW Golf Composition Media(5.8-inch)
u
- VW Polo Composition Media(6.5-inch)
www.car-solutions.com support@car-solutions.com
Activation by original buttons
o m
Button Function Operation Remarks
.c
1 Changing
Modes
Press the button 2 seconds long. Order: HDMI → NAVI → AV2 → OEM
4 MENU
ns
1 1 Shortcut to
Each modes
MENU Press the button 3 times quickly. < OEM → AV2 >
System If you visit car service center, you can lock the all
3 1 Locking / Press the button 10 seconds long. functions of this device. It is only possible to use the
tio
MENU Unlocking OEM functions under it is locked.
Head Unit Controllers Buttons marked Back to OEM Press the buttons short. Return to the OEM mode in any modes.
with yellow
u
Changing mode
2 to Front View Press the button 2 seconds long.
It changes the screen from any modes to AV1 mode
directly.
▽(Down) CAM mode(AV1)
ol 3 Reset to factory
You can use this function when you get in trouble to
default setting Press the button 10 seconds long.
see the screen while setting the screen.
ENTER and power.
r-s
2
4 Enter into the
setting menu
Press the button 5 seconds long.
All functions of setting menu is controlled by a touch
screen of the OEM monitor.
CAR
ca
www.car-solutions.com support@car-solutions.com
DIP Switch Settings
OFF
ON: ▼
m
OFF:▲
ON
Pin
o
ON(▼) OFF(▲) No.6 No.7 No.8 No.9 No.10 Car Models
No.
.c
1 HDMI Mode Skip HDMI Mode OFF(▲) OFF(▲) OFF(▲) OFF(▲) OFF(▲)
(Composition Media / 400*240)
2 Navigation Mode Skip Navigation Mode ON(▼) OFF(▲) OFF(▲) OFF(▲) OFF(▲) Golf / 8-inch Screen
ns
(Discover Pro / 800*480)
3 External Rear View Camera Original Rear View Camera ON(▼) OFF(▲) OFF(▲) ON(▼) OFF(▲) Golf, Polo / 6.5-inch Screen
(Composition Media / 800*480)
tio
4
Camera(AV1 Mode) Camera(AV1 Mode)
u
ol
7
r-s
8 Selection of car model
9
ca
10
www.car-solutions.com support@car-solutions.com
Settings
m
Button Function Operation
o
Enter into the Press the ‘CAR’ button
CAR
setting menu 5 seconds long.
(Head Unit Controller)
.c
ns
All functions of setting menu of IW04VW is controlled
Touch Screen
(OEM Monitor)
by a touch screen of the OEM monitor.
u tio
1. Enter into the setting menu.
<Press the ‘CAR’ button 5 seconds long.>
ol
- HDMI & Navigation settings
r-s
- Rear view camera settings
- AV-input settings
ca
- System settings
- System information
www.car-solutions.com support@car-solutions.com
Settings
m
2. HDMI mode settings
- Mode selection: HDMI ↔ NAVI
o
- Image display
.c
= Adjust the values of brightness and contrast
Red-Green-Blue colors of HDMI display.
ns
- Screen position & size
= Entry Disabled / Not applicable
u tio
ol 3. NAVI mode settings
- Mode selection: NAVI ↔ HDMI
r-s
- Image display
= Adjust the values of brightness and contrast
Red-Green-Blue colors of NAVI display.
www.car-solutions.com support@car-solutions.com
Settings
m
4. Rear view camera settings
- Parking guide lines
o
= Adjust position of parking guide lines and
select the lines ‘ON or OFF’.
.c
- Parking distance control
= Adjust position of Parking Distance Control sensors
ns
to ‘LEFT or RIGHT’ and select PDC function ‘ON or OFF’.
- Image display
= Adjust the values of brightness and contrast
tio
Red-Green-Blue colors of Rear view camera display.
m
6. Automatic activation function(AV1)
- Shift gear from reverse to drive
o
- Shift gear from parking to drive
.c
* When you shift gear ‘from reverse to drive’ or ‘from parking to drive’,
it just works automatically during the activation time you selected.
ns
u tio
ol 7. AV2 settings
- Mode selection: AV2 ↔ AV1(Front view camera)
r-s
- Image display
= Adjust the values of brightness and contrast
Red-Green-Blue colors of AV2 display.
www.car-solutions.com support@car-solutions.com
Settings
m
8. System settings
- Safe mode
o
= Select the one of two between ‘ON and OFF’.
.c
* If you select ‘ON’, 3 modes(HDMI, NAVI and AV2) will be faded out
when the car is driven.
ns
- Factory default
= Reset all setting values to factory default setting.
u tio
ol 9. System information
- Mode name: IW04VW
r-s
- Firmware date: 2015 - 06 - 22 (Latest firmware date)
- = You can check the current firmware version date.
www.car-solutions.com support@car-solutions.com
Settings
m
10. Information of Dip switch settings
* You can check current positions of dip switch settings.
o
.c
ns
u tio
ex 1) ex 2)
Actual DIP switch values. (→) Actual DIP switch values. (→)
www.car-solutions.com support@car-solutions.com