Professional Documents
Culture Documents
1、Different fiber optic devices, material quality, gas, optical lenses, cutting patterns, etc., will affect the cutting speed and need to be
adjusted according to site conditions;
(The plate type used in this parameter: Q235 for carbon steel, 201 for stainless steel, 5# for aluminum, and H6 for copper. The thickness of
the plate is theoretical thickness, the actual thickness is slightly smaller 0.2~0.5mm)
2、Output power >2KW, it is recommended to select a cutting head with a suitable length according to the normally processed sheet.
3、Red parts are limiting materials,when laser cutting processess limiting materials the effect is reduced,and unable to process
continuously;
4、For cutting high-reflective materials such as copper and aluminum, it is necessary to pay attention to the adjustment process. The
limiting thickness is not recommended for continuous long-term processing. CHONG XIN laser can cut high anti-material under normal
cutting conditions, but it is not recommended for long-term cutting.
5、The test environment is 10 ° C ~ 35 ° C, the relative humidity is below 35%; there is no large-scale electrical equipment around, no
electromagnetic interference; power quality: three-phase unbalance <2.5%, line voltage fluctuation <5%;
6、Use a screw air compressor with a pressure of 1.6 MPa, a flow rate of 1.5 m3/h, an air dust content of less than 0.01 um, and an oil
content of less than 0.001 ppm. At the same time, it is recommended to have a gas storage tank of about 1m3 for batch processing.