Professional Documents
Culture Documents
Please let us know if you need any other information from our end.
Rajiv
==========================================
CSI Engineering Software Pvt. Ltd. (Technical Support)
E-169, Lower Ground Floor
Greater Kailash-3
Masjid Moth
Phone:011-41646528
Mobile: +91-9811927135
Installation Help Line : +91 99995 52138
==========================================
CIN :U72200DL2011PTC215216
In most of the flat slab projects, end of the slab is cantilevered with glazing on the edge as shown in the sketch
below.
In ETABS, so far we have been modelling null beam on the edge of the slab with UDL as shown in the image
below.
But on new ETABS version, at many of such null beams with UDL load, ETABS is showing an error of loss of load,
(screenshot not available as of now).
We want to know what is the correct way to model UDL on the edge of such cantilever slab.
Ketan B. Parmar
Mobile: 98925-14491
Hello:
It appears to be graphics issue and doesn't come every time. For example us reshape button and click on the area.
You will get lots of handles to modify the extents of the drawn slab. Close reshape and click on the area again. You
should not get the issue again.
Rajiv
==========================================
Greater Kailash-3
Masjid Moth
Phone:011-41646528
Mobile: +91-9811927135
==========================================
CIN :U72200DL2011PTC215216
Dear Sir
Ketan B. Parmar
Dear Ketan
Regards
Rajiv
We are in the middle of making one ETABS model, we are facing some issue while selecting the slab on
the 1st floor.
See the images below, dotted line indicating slab selection is going out of the model on the right portion of
building, and on left there seems to be a glitch too.
For your reference, EDB file is attached with this mail. (Issue on 1st floor)
Ketan B. Parmar
Mobile: 98925-14491