Professional Documents
Culture Documents
TEM
D
E
CONTENTS
SERVICE INFORMATION ............................ 2 AUDIO ................................................................ 4 F
System Description ................................................... 4
MODIFICATION NOTICE .................................... 2 Component Parts Location ....................................... 4
Information ................................................................ 2 Wiring Diagram - AUDIO - / LHD models ................. 5 G
Wiring Diagram - AUDIO - / RHD models ................. 6
PRECAUTION ..................................................... 3 Terminal and Reference Value for Audio Unit .......... 7
Precaution for Supplemental Restraint System
Symptom Chart ......................................................... 8 H
(SRS) "AIR BAG" and "SEAT BELT PRE-TEN-
SIONER" ................................................................... 3 AUDIO ANTENNA ............................................. 10
Location of Antenna .................................................10
I
AV
Wiring diagram has been changed. (Steering switch has been added.)
B
The Supplemental Restraint System such as “AIR BAG” and “SEAT BELT PRE-TENSIONER”, used along
with a front seat belt, helps to reduce the risk or severity of injury to the driver and front passenger for certain
types of collision. Information necessary to service the system safely is included in the “SUPPLEMENTAL C
RESTRAINT SYSTEM” and “SEAT BELTS” of this Service Manual.
WARNING:
• To avoid rendering the SRS inoperative, which could increase the risk of personal injury or death in
the event of a collision which would result in air bag inflation, all maintenance must be performed by D
an authorized NISSAN/INFINITI dealer.
• Improper maintenance, including incorrect removal and installation of the SRS, can lead to personal
injury caused by unintentional activation of the system. For removal of Spiral Cable and Air Bag E
Module, see the “SUPPLEMENTAL RESTRAINT SYSTEM”.
• Do not use electrical test equipment on any circuit related to the SRS unless instructed to in this
Service Manual. SRS wiring harnesses can be identified by yellow and/or orange harnesses or har-
F
ness connectors.
AV
AUDIO SYSTEM
For details of audio system operation procedure, refer to owner's manual.
Component Parts Location INFOID:0000000004227863
JSNIA1933ZZ
AV
TKWT8473E
P
TKWT8474E
Terminal
Signal Condition
(Wire color) Reference value
Item input/ B
Ignition (Approx.)
+ – output Operation
switch
2 3
Audio signal front LH Output ON Receive audio signal D
(W) (BR)
SKIB3609E
E
F
4 5
Audio signal rear LH Output ON Receive audio signal
(W) (R)
G
SKIB3609E
11 12
(G)*1 (SB)*1 Audio signal front RH Output ON Receive audio signal
M
(V)*2 (BR)*2
SKIB3609E
N
O
13 14
Audio signal rear RH Output ON Receive audio signal
(LG) (GR)
P
SKIB3609E
15 Steering switch
Ground – ON – 0V
(BR) ground
RELATED TO AUDIO
• The majority of the audio malfunctions are the result of outside causes (bad cassette, electromagnetic inter-
ference, etc.). Check the symptoms below to diagnose the malfunction.
• The vehicle itself can be a source of noise if noise prevention parts or electrical equipment is malfunctioning.
Check if noise is caused and/or changed by engine speed, ignition switch turned to each position, and oper-
ation of each piece of electrical equipment, and then determine the cause.
AV
SKIB7298E